Effect of molten salt on re-pyrolysis behaviors of heavy bio-oil

CHEN Tao; LUO Ze-jun; WANG Chu; ZHU Xi-feng

doi:10.1016/S1872-5813(22)60068-9

Volume 51 Issue 6

Jun. 2023

Turn off MathJax

Article Contents

Article Navigation > Journal of Fuel Chemistry and Technology > 2023 > 51(6): 711-717

CHEN Tao, LUO Ze-jun, WANG Chu, ZHU Xi-feng. Effect of molten salt on re-pyrolysis behaviors of heavy bio-oil[J]. Journal of Fuel Chemistry and Technology, 2023, 51(6): 711-717. doi: 10.1016/S1872-5813(22)60068-9

Citation:

CHEN Tao, LUO Ze-jun, WANG Chu, ZHU Xi-feng. Effect of molten salt on re-pyrolysis behaviors of heavy bio-oil[J]. Journal of Fuel Chemistry and Technology, 2023, 51(6): 711-717. doi: 10.1016/S1872-5813(22)60068-9

Citation:

PDF( 789 KB)

Effect of molten salt on re-pyrolysis behaviors of heavy bio-oil

doi: 10.1016/S1872-5813(22)60068-9

School of Engineering Science, University of Science and Technology of China, Hefei 230026, China

Funds: The project was supported by the National Key Research and Development Program of China (2018YFB1501404)

Received Date: 2022-06-30
Accepted Date: 2022-10-25
Rev Recd Date: 2022-10-11

Available Online: 2022-10-26

Publish Date: 2023-06-15

Abstract

Abstract

The effects of KCl-ZnCl₂ molten salt on the pyrolysis characteristics and pyrolysis products of heavy bio-oil at 400, 500 and 600℃ were studied. The results showed that molten salt increased the solid yield of heavy bio-oil pyrolysis and decreased the gas yield. Some compounds such as phenol, cresol, ethylphenol and 4-propylphenol had good enrichment effect, especially the relative concentration of cresol increased from 8.82% to 20.85% at 400℃, while the relative concentration of phenol increased from 2.18% to 8.62% at 600℃. During formation of char, molten salt reduced the content of carbon and increased the content of oxygen, increased the BET surface area and total pore volume of pores. Molten salt promoted formation of pore structure of the solid product and increased its average pore diameter.
- heavy bio-oil,
- molten salt,
- pyrolysis,
- component analysis

FullText(HTML)

References(22)

References

[1]	HU H S, WU Y L, YANG M D. Fractionation of bio-oil produced from hydrothermal liquefaction of microalgae by liquid-liquid extraction[J]. Biomass Bioenerg,2018,108:487−500. doi: 10.1016/j.biombioe.2017.10.033
[2]	马亚凯, 袁鑫华, 罗泽军, 朱锡锋. 精馏系统内真空度对生物油模型化合物蒸馏特性的影响[J]. 燃料化学学报,2022,50(2):160−165. doi: 10.1016/S1872-5813(21)60140-8 MA Ya-kai, YUAN Xin-hua, LUO Ze-jun, ZHU Xi-feng. Influence of vacuum degrees in rectification system on distillation characteristics of bio-oil model compounds[J]. J Fuel Chem Technol,2022,50(2):160−165. doi: 10.1016/S1872-5813(21)60140-8
[3]	闫彩辉, 赵炜, 盛晨, 吴晓娜. 柱层析法在生物油分离方面应用的研究进展[J]. 林产化学与工业,2011,31(4):123−126. YAN Cai-hui, ZHAO Wei, SHENG Chen, WU Xiao-na. Research progress for separation of bio-oil by column chromatography[J]. Chem Ind Forest Prod,2011,31(4):123−126.
[4]	王储, 朱锡锋. 分级冷凝生物油组分富集与组分稳定性研究[J]. 燃料化学学报,2018,46(11):1315−1322. doi: 10.3969/j.issn.0253-2409.2018.11.005 WANG Chu, ZHU Xi-feng. Study on component enrichment and storage stability of bio-oils obtained from fractional condensation[J]. J Fuel Chem Technol,2018,46(11):1315−1322. doi: 10.3969/j.issn.0253-2409.2018.11.005
[5]	LI W, PAN C Y, SHENG L, LIU Z, CHEN P, LOU H, ZHENG X M. Upgrading of high-boiling fraction of bio-oil in supercritical methanol[J]. Bioresour Technol,2011,102(19):9223−8. doi: 10.1016/j.biortech.2011.07.071
[6]	ZHANG X H, TANG W W, ZHANG Q, LI Y P, CHEN L G, XU Y, WANG C G, MA L L. Production of hydrocarbon fuels from heavy fraction of bio-oil through hydrodeoxygenative upgrading with Ru-based catalyst[J]. Fuel,2018,215:825−34. doi: 10.1016/j.fuel.2017.11.111
[7]	JIANG H T, AI N, WANG M, JI D X, JI J B. Experimental study on thermal pyrolysis of biomass in molten salt media[J]. Electrochem,2009,77(8):730−5. doi: 10.5796/electrochemistry.77.730
[8]	ZENG K, YANG X Y, XIE Y P, YANG H P, LI J, ZHONG D, ZUO H Y, NZIHOU A, ZHU Y J, CHEN H P. Molten salt pyrolysis of biomass: The evaluation of molten salt[J]. Fuel,2021,302:121103.
[9]	XIE Y P, ZENG K, FLAMANT G, YANG H P, LIU N, HE X, YANG X Y, NZIHOU A, CHEN H P. Solar pyrolysis of cotton stalk in molten salt for bio-fuel production[J]. Energy,2019,179:1124−32. doi: 10.1016/j.energy.2019.05.055
[10]	KONG W X, ZHAO F, GUAN H J, ZHAO Y F, ZHANG H S, ZHANG B. Highly adsorptive mesoporous carbon from biomass using molten-salt route[J]. J Mater Sci,2016,51(14):6793−800. doi: 10.1007/s10853-016-9966-8
[11]	NYGÅRD H S, OLSEN E. Effect of salt composition and temperature on the thermal behavior of beech wood in molten salt pyrolysis[J]. Energy Procedia,2014,58:221−8. doi: 10.1016/j.egypro.2014.10.432
[12]	KUDSY M, KUMAZAWA H, SADA E. Pyrolysis of kraft lignin in molten ZnCl₂-KCl media with tetralin vapor addition[J]. Can J Chem Eng,1995,73(3):411−5. doi: 10.1002/cjce.5450730319
[13]	AI N, ZENG G N, ZHOU H Y, HE Y T. Co-production of activated carbon and bio-oil from agricultural residues by molten salt pyrolysis[J]. Bioresour,2013,8(2):1551−62.
[14]	谢迎谱. 生物质熔融碳酸盐热解与气化过程实验研究[D]. 武汉: 华中科技大学, 2020. XIE Yin-pu. Experimental study on biomass pyrolysis and gasification with molten carbonates[D]. Wuhan: Huazhong University of Science and Technology, 2020.
[15]	WANG W L, REN X Y, CHANG J M, CAI L P, SHI S Q. Characterization of bio-oils and bio-chars obtained from the catalytic pyrolysis of alkali lignin with metal chlorides[J]. Fuel Process Technol,2015,138:605−11. doi: 10.1016/j.fuproc.2015.06.048
[16]	杨耀钧, 刁瑞, 王储, 朱锡锋. 不同金属氧化物对重质生物油再裂解的比较性研究[J]. 化工学报,2021,72(11):5820−5830. doi: 10.11949/0438-1157.20210895 YANG Yao-jun, DIAO Rui, WANG Chu, ZHU Xi-feng. Catalytic effect of different metal oxides on pyrolysis behaviors of heavy bio-oil: A comparative study[J]. CIESC J,2021,72(11):5820−5830. doi: 10.11949/0438-1157.20210895
[17]	LUO Z J, ZHU X F, WANG C, WANG Y S, ZHU X F. Comparative study on the evolution of physicochemical properties of tar obtained from heavy fraction of bio-oil at different heating rates[J]. J Anal Appl Pyrolysis,2020,150:104854.
[18]	SEVILLA M, MOKAYA R. Energy storage applications of activated carbons: Supercapacitors and hydrogen storage[J]. Energy Environ Sci,2014,7(4):1250−1280. doi: 10.1039/C3EE43525C
[19]	SHANG H S, LU Y J, ZHAO F, CHAO C, ZHANG B, ZHANG H S. Preparing high surface area porous carbon from biomass by carbonization in a molten salt medium[J]. RSC Adv,2015,5(92):75728−75734. doi: 10.1039/C5RA12406A
[20]	MOLINA S M, RODRÍGUEZ R F. Role of chemical activation in the development of carbon porosity[J]. Colloid Surface A,2004,241(1/3):15−25. doi: 10.1016/j.colsurfa.2004.04.007
[21]	PORADA S, SCHIPPER F, ASLAN M, ANTONIETTI M, PRESSER V, FELLINGER T P. Capacitive deionization using biomass-based microporous salt-templated heteroatom-doped carbons[J]. ChemSusChem,2015,8(11):1867−1874. doi: 10.1002/cssc.201500166
[22]	DÍEZ N, FUERTES A B, SEVILLA M. Molten salt strategies towards carbon materials for energy storage and conversion[J]. Energy Storage Mater,2021,38:50−69. doi: 10.1016/j.ensm.2021.02.048