Catalytic degradation of toluene over Cu-Mn-Ce-Zr/TiO2 coupled with low temperature plasma
-
摘要: 以TiO2为载体, 采用等体积浸渍法制备了负载型CuxMn1-xCe0.75Zr0.25/TiO2(x=1.0、0.75、0.5、0.25、0)负载型催化剂, 采用XRD、H2-TPR、O2-TPD和XPS等方法对催化剂进行了表征, 并通过低温等离子体协同催化剂对大流量的甲苯模拟废气进行了催化降解反应研究。结果表明, Cu和Mn单主金属催化剂的活性优于Cu-Mn双主金属催化剂, 其原因是双金属催化剂中Mn的添加减弱了Cu与助剂Ce之间的相互作用, 使得催化剂的晶格氧减少, 低温还原性能降低。在反应初期, 甲苯降解主要依赖于催化剂的活性, 具有较好的低温还原性以及丰富的氧空穴和晶格氧含量的CuCe0.75Zr0.25/TiO2的活性最好; Mn具有较强的O3分解能力, 当等离子体比能密度(SED)增加到一定值后, 等离子体与催化剂的协同作用增强, 从而使得MnCe0.75Zr0.25/TiO2催化剂活性高于CuCe0.75Zr0.25/TiO2, 强化了甲苯的脱除。
-
关键词:
- 低温等离子体 /
- Cu-Mn双金属催化剂 /
- 协同催化 /
- 甲苯降解
Abstract: A series of supported CuxMn1-xCe0.75Zr0.25/TiO2 (x = 1.0, 0.75, 0.5, 0.25, 0) catalysts were prepared by impregnation and characterized by XRD, H2-TPR, O2-TPD and XPS; the performance of CuxMn1-xCe0.75Zr0.25/TiO2 catalysts in the degradation of toluene coupled with low temperature plasma under high space velocity was then investigated. The results indicate that the composite catalysts with single Cu or Mn as the main active component exhibit higher activity than those with double Cu and Mn components; the addition of second component may weaken the interaction between Cu and Ce, leading to a decrease in the content of lattice oxygen and the reducibility at low temperature. The CuCe0.75Zr0.25/TiO2 catalyst exhibits superior performance for toluene oxidation in the initial reaction stage, owing to its high content of lattice oxygen and oxygen vacancies. With the increase of the specific energy density (SED) of low temperature plasma, the concentration of O3 increases and the MnCe0.75Zr0.25/TiO2 catalyst then displays higher activity in toluene degradation than CuCe0.75Zr0.25/TiO2, because of the prominent enhancement of synergistic effect between plasma and catalyst over the former MnCe0.75Zr0.25/TiO2 catalyst. -
表 1 CuxMn1-xCZ/T催化剂的表面物种
Table 1 Surface species of the CuxMn1-xCZ/T catalysts
Catalyst (Cu+Mn)/Ti(%) Ce3+/Ce4+ Olat/Oad CuCZ/T 2.00 0.35 5.86 Cu0.75Mn0.25CZ/T 2.58 0.31 2.06 Cu0.5Mn0.5CZ/T 2.58 0.31 0.68 Cu0.25Mn0.75CZ/T 2.52 0.31 0.73 MnCZ/T 1.60 0.25 4.91 表 2 CuxMn1-xCZ/T催化剂上甲苯转化率为99%时对应的SED值
Table 2 SED values at a toluene conversion of 99% over the CuxMn1-xCZ/T catalysts
Catalyst CuCZ/T Cu0.75Mn0.25CZ/T Cu0.5Mn0.5CZ/T Cu0.25Mn0.75CZ/T MnCZ/T SED /(J·L-1) 900 610 695 800 423 -
[1] 陈颖, 叶代启, 刘秀珍, 吴军良, 黄碧纯, 郑雅楠.我国工业源VOCs排放的源头追踪和行业特征研究[J].中国环境科学, 2012, 32(1):48-55. doi: 10.3969/j.issn.1000-6923.2012.01.008CHEN Ying, YE Dai-qi, LIU Xiu-zhen, WU Jun-liang, HUANG Bi-chun, ZHENG Ya-nan. Source tracing and characteristics of industrial VOCs emissions in China[J]. China Environ Sci, 2012, 32(1):48-55. doi: 10.3969/j.issn.1000-6923.2012.01.008 [2] KARUPPIAH J, SIVACHANDIRAN L, KARVEMBU R, SUBRAHMANYAM C. Catalytic nonthermal plasma reactor for the abatement of low concentrations of isopropanol[J]. Chem Eng J, 2010, 165(1):194-199. doi: 10.1016/j.cej.2010.09.017 [3] 胡辉, 李胜利, 杨长河, 李劲.放电等离子体处理挥发性有机物的研究进展[J].高电压技术, 2002, 28(3):43-47. doi: 10.3969/j.issn.1003-6520.2002.03.018HU Hui, LI Sheng-li, YANG Chang-he, LI Jin. The progress on study of treatment of volatile organic compounds by discharge plasma[J]. High Volt Eng, 2002, 28(3):43-47. doi: 10.3969/j.issn.1003-6520.2002.03.018 [4] DOU B J, LIU D L, ZHANG Q, ZHAO R Z, HAO Q L, BIN F, CAO J G. Enhanced removal of toluene by dielectric barrier discharge coupling with Cu-Ce-Zr supported ZSM-5/TiO2/Al2O3[J]. Catal Commun, 2017, 92:15-18. doi: 10.1016/j.catcom.2016.12.024 [5] FAN H Y, SHI C, LI X S, ZHAO D Z, XU Y, ZHU A M. High-efficiency plasma catalytic removal of dilute benzene from air[J]. J Phys D:Appl Phys, 2009, 42(22):225105-225109. doi: 10.1088/0022-3727/42/22/225105 [6] ZHANG H B, LI K, SUN T H, JIA J P, LOU Z Y, FENG L L. Removal of styrene using dielectric barrier discharge plasmas combined with sol-gel prepared TiO2 coated λ-Al2O3[J]. Chem Eng J, 2014, 241:92-102. doi: 10.1016/j.cej.2013.12.019 [7] 党小庆, 周宇翔, 黄家玉, 朱海瀛, 秦彩虹.气体循环条件下等离子体催化氧化吸附态苯[J].环境工程学报, 2015, 9(3):1355-1360. http://d.old.wanfangdata.com.cn/Periodical/hjwrzljsysb201503061DANG Xiao-qing, ZHOU Yu-xiang, HUANG Jia-yu, ZHU Hai-ying, QIN Cai-hong. Plasma-catalytic decomposition of adsorbed benzene withgas circulation[J]. Chin J Environ Eng, 2015, 9(3):1355-1360. http://d.old.wanfangdata.com.cn/Periodical/hjwrzljsysb201503061 [8] 关绣娟, 叶代启, 黄海保.介质阻挡放电-催化降解空气中甲苯的研究[J].环境工程学报, 2008, 2(7):977-982. http://d.old.wanfangdata.com.cn/Periodical/hjwrzljsysb200807024GUAN Xiu-juan, YE Dai-qi, HUANG Hai-bao. Study on toluene destruction in air stream by dielectric barrier discharge combined with catalytic system[J]. Chin J Environ Eng, 2008, 2(7):977-982. http://d.old.wanfangdata.com.cn/Periodical/hjwrzljsysb200807024 [9] HASAN M A, ZAKI M I, PASUPULETY L, KUMARI K. Promotion of the hydrogen peroxide decomposition activity of manganese oxide catalysts[J]. Appl Catal A:Gen, 1999, 181(1):171-179. doi: 10.1016/S0926-860X(98)00430-X [10] 张晓玉, 刘志敏, 魏振玲, 杜小春, 龚茂初.高性能甲烷催化燃烧催化剂的制备及其在天然气催化燃烧热水器上的应用[J].催化学报, 2006, 27(9):823-826. doi: 10.3321/j.issn:0253-9837.2006.09.015ZHANG Xiao-yu, LIU Zhi-min, WEI Zhen-ling, DU Xiao-chun, GONG Mao-chu. Preparation of high performance methane combustion catalyst and its application to natural gas catalytic combustion Fan-Boiler[J]. J Catal, 2006, 27:823-826. doi: 10.3321/j.issn:0253-9837.2006.09.015 [11] LI W B, CHU W B, ZHUANG M, HUA J. Catalytic oxidation of toluene on Mn-containing mixed oxides prepared in reverse microemulsions[J]. Catal Today, 2004, 93(3):205-209. doi: 10.1016-j.cattod.2004.06.042/ [12] 李洪芳, 刘雪松, 郭存霞, 刘统, 罗孟飞, 鲁继青.载体对负载型金催化剂上甲醛催化氧化的影响[J].催化学报, 2009, 30(10):1001-1006. doi: 10.3321/j.issn:0253-9837.2009.10.007LI Hong-fang, LIU Xue-song, GUO Cun-xia, LIU Tong, LUO Meng-fei, LU Ji-qing. The influence of the carrier on the catalytic oxidation of formaldehyde on the loaded gold catalyst[J]. J Catal, 2009, 30(10):1001-1006. doi: 10.3321/j.issn:0253-9837.2009.10.007 [13] OKUMURA K, KOBAYASHI T, TANAKA H, NIWA M. Toluene combustion over palladium supported on various metal oxide supports[J]. Appl Catal B:Environ, 2003, 44(4):325-331. doi: 10.1016/S0926-3373(03)00101-2 [14] 姚水良, 毛灵爱, 张霞, 唐秀娟.等离子体复合微量贵金属催化反应器催化氧化苯的机理分析[J].高电压技术, 2017, 43(12):3973-3980. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=gdyjs201712022YAO Shui-liang, MAO Lin-ai, ZHANG Xia, TANG Xiu-juan. Mechanism analysis of benzene catalytic oxidation using plasma reactor with micro-level noble catalysts[J]. High Volt Eng, 2017, 43(12):3973-3980. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=gdyjs201712022 [15] SELLICK D R, ARANDA A, GARCÍA T, LÓPEZ J M, SOLAONA B, MASTRAL A M, MORGAN D J, CARLEY A F, TAYLOR S H. Influence of the preparation method on the activity of ceria zirconia mixed oxides for naphthalene total oxidation[J]. Appl Catal B:Environ, 2013, 132/133(1):98-106. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=8672af8c1216cc4b83f1de9a57e8c2df [16] ZHAO C C, HAO Q L, ZHANG Q, YAN N N, LIU J R, DOU B J, BIN F. Catalytic self-sustained combustion of toluene and reaction pathway over CuxMn1-xCe0.75Zr0.25/TiO2 catalysts[J]. Appl Catal A:Gen, 2019, 569:66-74. doi: 10.1016/j.apcata.2018.10.034 [17] GUO X L, LI J, ZHOU R X. Catalytic performance of manganese doped CuO-CeO2 catalysts for selective oxidation of CO in hydrogen-rich gas[J]. Fuel, 2016, 163:56-64. doi: 10.1016/j.fuel.2015.09.043 [18] SANTOS V P, PEREIRA M F R, ÓRFÄO J J M, FIGUEIREDO J L. The role of lattice oxygen on the activity of manganese oxides towards the oxidation of volatile organic compounds[J]. Appl Catal B:Environ, 2010, 99(1/2):353-363. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=57d1e827a80a1170572e3352c67ee07b [19] LI L M, JING F L, YAN J L, JING J, CHU W. Highly effective self-propagating synthesis of CeO2-doped MnO2 catalysts for toluene catalytic combustion[J]. Catal Today, 2017, 297:167-172. doi: 10.1016/j.cattod.2017.04.053 [20] DENG Q F, REN T Z, BAO A, LIU Y P, YUAN Z Y. Mesoporous Cex Zr1-xO2 solid solutions supported CuO nanocatalysts for toluene total oxidation[J]. J Ind Eng Chem, 2014, 20(5):3303-3312. doi: 10.1016/j.jiec.2013.12.012 [21] TANG W X, WU X F, LIU G, LI S D, LI D Y, LI W H, CHEN Y F. Preparation of hierarchical layer-stacking Mn-Ce composite oxide for catalytic total oxidation of VOCs[J]. J Rare Earth, 2015, 33(1):62-69. doi: 10.1016/S1002-0721(14)60384-7 [22] DOU B J, LV G, WANG C, HAO Q L, HUI K S. Cerium doped copper/ZSM-5 catalysts used for the selective catalytic reduction of nitrogen oxide with ammonia[J]. Chem Eng J, 2015, 270:549-556. doi: 10.1016/j.cej.2015.02.004 [23] DOU B J, BIN F, WANG C, JIA Q Z, LI J. Discharge characteristics and abatement of volatile organic compounds using plasma reactor packed with ceramic Raschig rings[J]. J Electrost, 2013, 71(5):939-944. doi: 10.1016/j.elstat.2013.08.003