超临界甲烷在活性炭上的吸附平衡分析

郑青榕; 廖海峰; 解晨; 智会杰

超临界甲烷在活性炭上的吸附平衡分析

集美大学轮机工程学院, 福建厦门 361021

基金项目: 福建省高等学校新世纪优秀人才计划(Z80136); 福建省科技厅高校专项(JK2010030); 福建省自然科学基金(2011J01324)。

详细信息

通讯作者:
郑青榕(1967-), 男, 福建永定人,博士,教授,从事燃气(氢气、天然气)吸附储存研究, E-mail: zhengqr@jmu.edu.cn 或qrzheng816@sina.com, Tel: 0592-6183533, Fax: 0592-6180332.

中图分类号: TQ028
计量
- 文章访问数: 2158
- HTML全文浏览量: 30
- PDF下载量: 998
- 被引次数: 0
出版历程
- 收稿日期: 2011-09-26
- 修回日期: 2011-12-03
- 刊出日期: 2012-07-31

Adsorption equilibrium of supercritical methane on activated carbon

Institute of Marine Engineering, Jimei University, Xiamen 361021, China

摘要

摘要: 为分析由吸附平衡时的热力参数确定吸附量、吸附模型和等量吸附热精度的影响因素,选择在温度268.15~338.15 K和压力0~13.5 MPa测试的甲烷在Ajax活性炭上的吸附平衡数据,通过引入甲烷分子可进入活性炭吸附空间内的容积和可以不考虑甲烷在孔内吸附的临界孔宽的概念,依据甲烷在吸附平衡前后的总量守恒,确定甲烷在吸附池内的总量、绝对吸附量和过剩吸附量三者之间的关系式。结果表明,在引入吸附质分子可进入吸附空间内的容积和临界孔宽后,经由活性炭的孔径分布(PSD),可以准确计算甲烷在活性炭上的过剩吸附量;应用实验数据非线性回归Toth方程参数后,可由Gibbs关于吸附的定义确定甲烷在活性炭上的绝对吸附量。比较结果时发现,由于未考虑本体相中甲烷分子对吸附甲烷分子的影响,采用过剩吸附量的等量吸附线标绘确定的等量吸附热数值偏高,工程应用时应由绝对吸附量来确定等量吸附热。
- 甲烷 /
- 活性炭 /
- 吸附平衡 /
- 吸附模型
Abstract: Equilibrium adsorption data of methane on Ajax activated carbon were volumetrically measured under a temperature of 268.15~338.15 K and a pressure up to 13.5 MPa. Accessible volumes for methane molecules and critical pore width for methane effective adsorption were introduced; on the basis of these concepts, the mass balance of the adsorbate confined within the adsorption cell was used to determine the relationship among the total amount, excess adsorption amount and absolute adsorption amount. By considering the accessible volume and critical pore width, the excess adsorption amount was obtained by the pore size distribution (PSD) determined by Nonlocal Density Functional Theory (NDFT) calculation. The equilibrium adsorption data were fitted by Toth model through nonlinear regression, which was verified the accuracy in predicting the absolute adsorption amount. The isosteric heat of methane adsorption on activated carbon was over-estimated by using the excess amounts, but underestimated by using the total amounts. The isosteric heat of adsorption should be determined from the adsorption isosteres of absolute adsorption amount when considering the thermal effect in adsorption process.
- methane /
- activated carbon /
- adsorption equilibrium /
- adsorption model

HTML全文

参考文献(17)

DUBAND L, RAVEX A, CHAUSSY J. Adsorption isotherms of helium on activated charcoal[J]. Cryogenics, 1987, 27(7): 397-400.

MALBRUNOT P, VIDAL D, VERMESSE J, CHAHINE R, BOSE T K. Adsorbent helium density measurement and its effect on adsorption isotherms at high pressure[J]. Langmuir, 1997, 13 (3): 539-544.

DO D D, DO H D. Appropriate volumes for adsorption isotherm studies: The absolute void volume, accessible pore volume and enclosing particle volume[J]. J Colloid Interface Sci, 2007, 316(2): 317-330.

BAGHERI N, ABEDI J. Adsorption of methane on corn cobs based activated carbon[J]. Chem Eng Res Des, 2011, 89(10): 2038-2043.

MURATA K, MIYAWAKI J, KANEKO K. A simple determination method of the absolute adsorbed amount for high pressure gas adsorption[J]. Carbon, 2003, 40(3): 425-428.

DO D D, DO H D. Adsorption of supercritical fluids in non-porous and porous carbons: Analysis of adsorbed phase volume and density[J]. Carbon, 2003, 41(9): 1777-1791.

FLORIAN O M. Determination of absolute adsorption in highly ordered porous media[J]. Surf Sci, 2009, 603(10/12): 1979-1984.

ALEJANDRO S, MARIO T. Thermal effect of the adsorption heat on an adsorbed natural gas storage and transportation systems[J]. Appl Thermal Eng, 2009, 29(13): 2617-2623.

YANG X D, ZHENG Q R, GU A Z, LU X S. Experimental studies of the performance of adsorbed natural gas storage system during discharge[J]. Appl Thermal Eng, 2005, 25(4): 591-601.

郑青榕, BIRKETT G, DO D D. 甲烷在活性炭上吸附的实验及理论分析[J]. 天然气化工, 2009, 34(1): 41-44. (ZHENG Qing-ron, BIRKETT G, DO D D. Theoretical and experimental analysis of methane adsorption on activated carbon[J]. Natural Gas Chemical Industry, 2009, 34(1): 41-44.)

LI M, GU A Z, LU X S, WANG R S. Determination of the adsorbate density from supercritical gas adsorption equilibrium data[J]. Carbon, 2003, 41(3): 585-588.

NIESZPOREK K. Potential theory approach as a powerful tool in theoretical prediction of mixed-gas adsorption equilibria and their accompanying calorimetric effects[J]. Chem Eng Sci, 2005, 60(10): 2763-2769.

SETZMANN U, WAGNER W J. A new EOS and tables of thermodynamic properties for methane covering the range from the melting line to 635K at pressures up to 1 000 MPa[J]. J Phys Chem Ref Data, 1991, 20(6): 1061-1156.

BIRKETT G, DO D D. New method to determine PSD using supercritical adsorption: Applied to methane adsorption in activated carbon[J]. Langmuir, 2006, 22(18): 7622-7630.

MENON P G. Adsorption at high pressures[J]. Chem Rev, 1968, 68(3): 277-294.

SANDLER S I. Chemical and engineering thermodynamics[M]. 3rd ed. New York: Wiley, 1999: 86-91.

MEEKS O R, RYBOLT T R. Correlations of adsorption energies with physical and structural properties of adsorbate molecules[J]. J Colloid Interface Sci, 1997, 196 (1): 103-109.

施引文献

资源附件(0)

访问统计