O<sub>2</sub>/CO<sub>2</sub>气氛下木醋调质石灰石再燃/先进再燃脱硝性能研究

刘洪涛; 韩奎华; 路春美; 李辉

O₂/CO₂气氛下木醋调质石灰石再燃/先进再燃脱硝性能研究

山东大学能源与动力工程学院, 山东济南 250061

基金项目: 山东大学自主创新基金(2010TS020); 山东大学研究生自主创新基金(yzc11058)。

详细信息

通讯作者:
路春美,韩奎华;E-mail:cml@sdu.edu.cn,hankh@163.com;Tel:0531-88392264。

中图分类号: TK224; X511
计量
- 文章访问数: 1661
- HTML全文浏览量: 31
- PDF下载量: 684
- 被引次数: 0
出版历程
- 收稿日期: 2012-10-16
- 修回日期: 2012-12-26
- 刊出日期: 2013-02-28

Experimental study on reburning/advanced reburning performance of limestone modified by wood vinegar for NO reduction under O₂/CO₂ atmosphere

School of Energy and Power Engineering, Shandong University, Jinan 250061, China

摘要

摘要: 在O₂/CO₂气氛下利用沉降炉脱硝实验台,对木醋调质石灰石和醋酸钙的再燃/先进再燃脱硝特性以及氨气的选择性非催化还原脱硝特性进行了研究。结果表明,木醋调质石灰石和醋酸钙的再燃脱硝效率随温度的升高先提高后降低,1 323 K时获得最高脱硝效率分别为82.70%和78.52%;再燃脱硝氧浓度不宜过高,合适的再燃比为14%~17%,停留时间为0.8 s。氨气选择性非催化还原脱硝在1 173 K时获得最高脱硝效率为95.41%,温度窗口为1 142~1 335 K;随着氧浓度的增大,脱硝效率不断降低,反应适宜的氨氮比为1.5,停留时间为1.2 s。按氨氮比0.75向再燃区喷入氨气可显著提高木醋调质石灰石和醋酸钙的再燃脱硝效率,同时脱硝反应适宜的温度区间也得到显著拓宽,1 323 K时两者获得的先进再燃脱硝效率分别为93.49%和92.79%。
- O₂/CO₂ /
- 木醋液 /
- 醋酸钙 /
- 先进再燃 /
- NO /
- 选择性非催化还原
Abstract: NO reduction characteristics of reburning/advanced reburning using limestone modified by wood vinegar and calcium acetate, as well as selective non-catalytic reduction using ammonia, are investigated in a drop-tube system under O₂/CO₂ atmosphere. Results show that NO reduction efficiency of limestone modified by wood vinegar and calcium acetate through basic reburning increases first and then decreases with increasing temperature. The maximum NO reduction efficiency of 82.70% and 78.52% can be obtained at 1 323 K, respectively. High oxygen concentration is not conducive to NO reduction. The optimum reburning fuel fraction and residence time for basic reburning is 14%~17% and 0.8 s, respectively. The maximum NO reduction efficiency of selective non-catalytic reduction is 95.41% at 1 173 K in temperature window of 1 142~1 335 K. With increasing oxygen concentration, NO reduction efficiency declines continuously. The optimum [NH₃]/[NO] molar ratio and residence time for selective non-catalytic reduction is 1.5 and 1.2 s, respectively NO reduction efficiency of reburning is significantly increased, while the reaction temperature window is obviously broaden when ammonia is injected into reburning zone at [NH₃]/[NO] mol ratio of 0.75. The maximum NO reduction efficiency of limestone modified by wood vinegar and calcium acetate advanced reburning is 93.49% and 92.79% at 1 323 K, respectively.
- O₂/CO₂ /
- wood vinegar /
- calcium acetate /
- advanced reburning /
- NO /
- selective non-catalytic reduction

HTML全文

参考文献(22)

段伦博, 赵长遂, 李庆钊, 李英杰, 陈晓平. O₂/CO₂气氛下煤焦燃烧实验研究[J]. 燃料化学学报, 2009, 37(6): 654-658. (DUAN Lun-bo, ZHAO Chang-sui, LI Qing-zhao, LI Ying-jie, CHEN Xiao-ping. Experimental investigation on coal and char combustion in O₂/CO₂ mixture[J]. Journal of Fuel Chemistry and Technology, 2009, 37(6): 654-658.)

韩奎华, 路春美, 侯庆伟, 刘志超, 马传利, 高山. 煤在不同O₂/CO₂气氛下燃烧硫析出特性研究[J]. 燃料化学学报, 2004, 32(5): 517-521. (HAN Kui-hua, LU Chun-mei, HOU Qing-wei, LIU Zhi-chao, MA Chuan-li, GAO Shan. The characteristics of sulfur release During coal combustion in the mixed-CO₂ gas with different oxygen concentrations[J]. Journal of Fuel Chemistry and Technology, 2004, 32(5): 517-521.)

XIONG J, ZHAO H, ZHENG C, LIU Z, ZENG L, LIU H, QIU J. An economic feasibility study of O₂/CO₂ recycle combustion technology based on existing coal-fired power plants in China[J]. Fuel, 2009, 88(6): 1135-1142.

PAK P S, LEE Y D, AHN K Y. Characteristics and economic evaluation of a power plant applying oxy-fuel combustion to increase power output and decrease CO₂ emission[J]. Energy, 2010, 35(8): 3230-3238.

CROISET E, THAMBIMUTHU K V. NO_x and SO₂ emissions from O₂/CO₂ recycle coal combustion[J]. Fuel, 2001, 80(14): 2117-2121.

谢芳, 张军, 盛昌栋, 张永春, 陈洁. O₂/CO₂气氛下CH₄再燃还原NO的实验研究[J]. 工程热物理学报, 2010, 31(9): 1599-1602. (XIE Fang, ZHANG Jun, SHENG Chang-dong, ZHANG Yong-chun, CHEN Jie. Experimental study on reduction of NO by CH₄ reburning in O₂/CO₂[J]. Journal of Engineering Thermophysics, 2010, 31(9): 1599-1602.)

牛胜利, 路春美, 高攀, 韩奎华, 耿萍, 程中杰. 生物质再燃降低NO_x排放的实验研究[J]. 燃料化学学报, 2008,36(5): 583-587. (NIU Sheng-li, LU Chun-mei, GAO Pan, HAN Kui-hua, GENG Ping, CHENG Zhong-jie. NO_x reduction using biomass as reburning fuel[J]. Journal of Fuel Chemistry and Technology, 2008, 36(5): 583-587.)

牛胜利, 韩奎华, 路春美. 生物质先进再燃脱硝特性研究[J]. 燃料化学学报, 2010, 38(6): 745-751. (NIU Sheng-li, HAN Kui-hua, LU Chun-mei. Study on nitrogen oxides reduction by advanced biomass reburing process[J]. Journal of Fuel Chemistry and Technology, 2010, 38(6): 745-751.)

韩奎华, 路春美, 牛胜利, 高攀. 气体先进再燃脱硝试验研究[J]. 中国电机工程学报, 2009, 29(20): 47-51. (HAN Kui-hua, LU Chun-mei, NIU Sheng-li, GAO Pan. Experimental study on advanced gas reburning for NO_x reduction[J]. Proceedings of the CSEE, 2009, 29(20): 47-51.)

NIMMO W, PATSIAS A A, HAMPARTSOUMIAN E, GIBBS B M, WILLIAMS P T. Simultaneous reduction of NO and SO₂ emissions from coal combustion by calcium magnesium acetate[J]. Fuel, 2004, 83(2): 149-155.

NIMMO W, PATSIAS A A, HALL W J, WILLIAMS P T. Characterization of a process for the in-furnace of NO_x, SO₂ and HCl by carboxylic salts of calcium[J]. Ind Eng Chem Res, 2005, 44(12): 4484-4494.

NIMMO W, PATSIAS A A, HAMPARTSOUMIAN E, GIBBS B M, FAIRWEATHER M, WILLIAMS P T. Calcium magnesium acetate and urea advanced reburning for NO control with simultaneous SO₂ reduction[J]. Fuel, 2004, 83(9): 1143-1150.

PATSIAS A A, NIMMO W, GIBBS B M, WILLIAMS P T. Calcium-based sorbents for simultaneous NO_x/SO_x reduction in a down-fired furnace[J]. Fuel, 2005, 84(14/15): 1864-1873.

NIU S L, HAN K H, ZHAO J L, LU C M. Experimental study on nitric oxide reduction through calcium propionate reburning[J]. Energy, 2011, 36(2): 1003-1009.

王海英, 杨国亭, 周丹. 木醋液研究现状及其综合利用[J]. 东北林业大学学报, 2004, 32(5): 55-57. (WANG Hai-ying, YANG Guo-ting, ZHOU Dan. Research situation and comprehensive utilization of wood vinegar[J]. Journal of Northeast Forestry University, 2004, 32(5): 55-57.)

YATAGAI M, NISHIMOTO M, HORI K, OHIRA T, SHIBATA A. Termiticidal activity of wood vinegar, its components and their homologues[J]. J Wood Sci, 2002, 48(4): 338-342.

刘洪涛, 韩奎华, 路春美. 基于无模式法推断木醋调质石灰石热解动力学参数[J]. 中国电机工程学报, 2012, 32(26): 31-36. (LIU Hong-tao, HAN Kui-hua, LU Chun-mei. Inference of the thermal decomposition parameters of limestone modified by wood vinegar based on model-free method[J]. Proceedings of the CSEE, 2012, 32(26): 31-36.)

PICHON S, BLACK G, CHAUMEIX N, YAHYAOUI M, SIMMIE J M, CURRAN H J, DONOHUE R. The combustion chemistry of a fuel tracer: Measured flame speeds and ignition delays and a detailed chemical kinetic model for the oxidation of acetone[J]. Combust Flame, 2009, 156(2): 494-504.

王志强, 孙绍增, 钱琳, 曹华丽, 秦裕琨. 煤气再燃还原氮氧化物的特性研究[J]. 中国电机工程学报, 2007, 27(20): 42-45. (WANG Zhi-qiang, SUN Shao-zeng, QIAN Lin, CAO Hua-li, Qin Yu-kun. Characteristic study on NO_x reduction with coal-gas reburning[J]. Proceedings of the CSEE, 2007, 27(20): 42-45.)

高攀, 路春美, 韩奎华, 甄天雷, 丁立新. 天然气/液化气先进再燃脱硝特性研究[J]. 煤炭学报, 2007, 32(11):1191-1195. (GAO Pan, LU Chun-mei, HAN Kui-hua, ZHEN Tian-lei, DING Li-xin. NO reduction performance of natural gas and petroleum gas advanced reburning[J]. Journal of China Coal Society, 2007, 32(11): 1191-1195.)

韩奎华, 路春美, 王永征, 牛胜利, 刘志超, 郝卫东. 选择性非催化还原脱硝特性试验研究[J]. 中国电机工程学报, 2008, 28(14): 80-85. (HAN Kui-hua, LU Chun-mei, WANG Yong-zheng, NIU Sheng-li, LIU Zhi-chao, HAO Wei-dong. Experimental study on De-NO_x characteristics of selective non-catalytic reduction[J]. Proceedings of the CSEE, 2008, 28(14): 80-85.)

刘洪涛, 牛胜利, 韩奎华, 路春美. 非催化烟气还原脱硝法脱硝特性的试验研究[J]. 动力工程, 2009, 29(9): 850-853. (LIU Hong-tao, NIU Sheng-li, HAN Kui-hua, LU Chun-mei. Experimental study on flue gas denitrification by selective non-catalytic reduction technology[J]. Journal of Power Engineering, 2009, 29(9): 850-853.)

施引文献

资源附件(0)

访问统计