SOFC中干甲烷浓度对Ni-YSZ阳极上反应的影响

由宏新; 高红杰; 陈刚; 阿布里提; 丁信伟

SOFC中干甲烷浓度对Ni-YSZ阳极上反应的影响

1.
大连理工大学, 化工学院, 辽宁大连 116024;
2.
弘前大学, 北日本新能源研究中心, 青森 030-0113, 日本

详细信息

通讯作者:
由宏新(1963- ),男,辽宁大连人,主要研究SOFC阳极,Tel:0411-84986283,E-mail:youhx@sina.com。

中图分类号: TM911.47
计量
- 文章访问数: 1469
- HTML全文浏览量: 15
- PDF下载量: 679
- 被引次数: 0
出版历程
- 收稿日期: 2012-08-20
- 修回日期: 2012-11-16
- 刊出日期: 2013-03-30

Effects of dry methane concentration on the methane reactions at Ni-YSZ anode in solid oxide fuel cell

1.
Chemical Environment and Life Science Division, Dalian University of Technology, Dalian 116024, China;
2.
New Energy Research Center of North Japan's, Hirosaki University, Aomori 030-0113, Japan

摘要

摘要: 为探讨固体氧化物燃料电池(solid oxide fuel cell, SOFC)中干甲烷浓度对反应的影响,采用色谱在线测量阳极尾气,总结阳极尾气的变化规律。在此基础上,分析干甲烷在固体氧化物燃料电池Ni-YSZ阳极上的反应,寻找干甲烷浓度与电流对电池阳极反应影响的数学关系。结果表明,随着电流密度的增加,低浓度甲烷按顺序发生CH₄+O^2- → CO+2H₂+2e^-、CH₄+2O^2- → CO+H₂O+H₂ +4e^-、CH₄+3O^2- → CO+2H₂O + 6e^-、CH₄+4O^2- → CO₂+2H₂O+8e^-反应,高浓度甲烷只发生甲烷的第一个氧化反应,中浓度甲烷发生前两个或前三个反应。依据法拉第第一定律及反应物之间的关系,确定甲烷的低、中、高浓度的判定依据分别为:q_v(CH₄)≤I/(4F)、I/(4F)≤q_v(CH₄)≤I/(2F)、q_v(CH₄)≥I/(2F)。
- 固体氧化物燃料电池 /
- 阳极 /
- 甲烷 /
- 反应
Abstract: The dry methane with different concentration was used to research the dry methane reactions at Ni-YSZ anode in solid oxide fuel cell (SOFC). The anode exhaust gases were measured by on-line chromatography. The reactions of dry methane with different concentration at SOFC Ni-YSZ anodes were analyzed by summarizing the anode exhaust gases regular pattern for different reactions. The mathematical relationships between dry methane concentration and current for different anode reaction were studied. As the oxygen ion concentration at the anode three-phase boundary increasing continuously, the following reactions with low concentration methane occurs in sequence of CH₄+O^2- → CO+2H₂+2e^-, CH₄+2O^2- → CO+H₂O+H₂+e^-, CH₄+3O^2- → CO+2H₂O+6e^- and CH₄+4O^2- → CO₂+2H₂O+8e^-. The first two or three reactions occurred with medium methane concentration, while the first reaction occurred only with high methane concentration. The judgment for methane in low, medium or high concentrations were q_v(CH₄)≤I/(4F)、I/(4F)≤q_v(CH₄)≤I/(2F)、q_v(CH₄)≥I/(2F) which are based on Faraday's first law and the relationship among the reactant species.
- solid oxide fuel cell /
- anode /
- methane /
- reaction

HTML全文

参考文献(9)

MICHAEL K B, MICHAEL V D B, STEVEN M. The influence of current density on the electro catalytic activity of oxide-based direct hydrocarbon SOFC anodes[J]. J Electrochem Soc, 2008, 155(11): 1202-1209.

KDENDALL K, FINNERTY C M, SAUUNDERS G, CHUNG J T. Effect of dilution methane entering an SOFC anode[J]. J Power Sources, 2002, 106: 323-327.

ABUDULA A, IHARA M, KOMIYAMA H, YAMADA K. Oxidation mechanism and effective anode thickness of SOFC for dry methane fuel[J]. Solid State Ionics, 1996, 86-88: 1203-1209.

由宏新, 高红杰, 陈刚, 阿布里提, 丁信伟. 低浓度干甲烷在SOFC Ni -YSZ阳极上的反应[J]. 燃料化学学报, 2011, 39(1): 69-74. (YOU Hong-xin, GAO Hong-jie, CHEN Gang, ABULIT·Abudula. DING Xin-wei. Reactions of low concentration dry methane at Ni-YSZ anode in the SOFCs[J]. Journal of Fuel Chemistry and Technology, 2011, 39(1): 69-74.)

YOU H, GAO H, CHEN G, ABULITI A, DING X. The conversion among reactions at Ni-based anodes in solid oxide fuel cells with low concentrations of dry methane[J]. J Power Sources, 2011, 196(5): 2779-2784.

ZHAN Z, LIN Y, PILLAI M, KIM I, BARNETT S A. High-rate electrochemical partial oxidation of methane in solid oxide fuel cells[J]. J Power Sources, 2006, 161(1): 460-465.

由宏新, 丁信伟, 阿布里提·阿布都拉. SOFC中不同浓度干甲烷在Ni-YSZ阳极上的反应[J]. 化工学报, 2006, 57(3): 620-625. (YOU Hong-xin, DING Xin-wei, ABULITI Abudula. Reactions of low and middle concentration dry methane on Ni-YSZ anode of SOFC[J]. Journal of Chemical Industry And Engineering(China), 2006, 57(3): 620-625.)

YOU H, ABULITI A, DING X, ZHOU Y. Reactions of low and middle concentration dry methane on Ni/YSZ anode of SOFC[J]. J Power Sources, 2007, 165(2): 722-727.

ETHAN S H, GAURAV K G, ZHU H, DEAN A M, KEE R J, MAIER L, DEUTSCHMANN O. Methane reforming kinetics within a Ni-YSZ SOFC anode support[J]. Appl Catal A, 2005, 295(1): 40-51.

施引文献

资源附件(0)

访问统计