生物质炭燃烧特性与动力学分析

熊绍武; 张守玉; 吴巧美; 郭熙; 董爱霞; 陈川; 郑红俊; 邓文祥; 刘大海; 唐文蛟

生物质炭燃烧特性与动力学分析

上海理工大学能源与动力工程学院热能工程研究所, 上海 200093

基金项目: 国家科技支撑计划(2012BAA04B01).

详细信息

通讯作者:
张守玉

中图分类号: TK6
计量
- 文章访问数: 1836
- HTML全文浏览量: 22
- PDF下载量: 1450
- 被引次数: 0
出版历程
- 收稿日期: 2013-06-01
- 修回日期: 2013-06-26
- 刊出日期: 2013-08-30

Investigation on combustion characteristics and kinetics of bio-char

School of Energy and Power Engineering, Institute of Thermal Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China

摘要

摘要: 利用小型固定床反应器对棉杆和木屑进行了炭化制焦实验,利用热重分析仪对制得的生物质炭进行氧化实验.基于综合反应速率方程推导了生物质炭氧化过程气固反应机理,并对热重实验结果进行拟合计算.实验结果表明,随着制焦炭化温度的升高,生物质炭的着火温度和燃尽温度升高,燃烧特性指数S减小;棉杆炭综合燃烧性能优于木屑炭.棉杆炭在低温段和高温段燃烧的反应机理不同,低温段燃烧反应的机理是片状内扩散反应机理,高温段燃烧反应的机理是球形界面化学反应机理.木屑炭的反应机理是球形界面化学反应机理.拟合计算求得的活化能并不能反映出生物质炭进行燃烧反应的难易程度.
- 生物质 /
- 生物质炭 /
- 燃烧特性 /
- 气固反应机理 /
- 反应动力学
Abstract: The bio-char from cotton stalk and sawdust was prepared using a tubular fixed bed, and the combustion characteristics of the resulted bio-chars were analyzed with a thermogravimetric analyzer. Based on the comprehensive reaction rate equation, the gas-solid reaction mechanism of the bio-char combustion was deduced, and the thermogravimetric data of the bio-char combustion were fitted. The results indicate that as the carbonization temperature increases, the ignition temperature and burnout temperature of the bio-chars increase, while the combustion performance index (S) decreases. The combustion characteristics of the cotton stalk charcoal are better than that of the sawdust charcoal. The reaction mechanisms for the cotton stalk charcoal combustion are different in different temperature ranges. The charcoal combustion in lower temperature range follows the planar internal diffusion reaction mechanism, while the globular interface reaction mechanism applies to higher temperature range. The combustion reaction of sawdust charcoal follows globular interface reaction mechanism during the whole oxidation process. The reaction reactivity of bio-char combustion can't be judged by the calculated activation energy.
- biomass /
- bio-char /
- combustion characteristic /
- gas-solid reaction mechanism /
- kinetics

HTML全文

参考文献(24)

张守玉, 黄凤豹, 彭定茂, 董刚, 宝田恭之. 低品质生物质的热解及低温催化气化研究[J]. 燃料化学学报, 2009, 37(6): 673-678. (ZHANG Shou-yu, HUANG Feng-bao, PENG Ding-mao, DONG Gang, TAKARADA Takayuki. Pyrolysis and low temperature catalytic gasification of manure[J]. Journal of Fuel Chemistry and Technology, 2009, 37(6): 673-678.)

张守玉, 彭定茂, 王秀军, 王健, 谷立莹, 刘洋, 戴锋. 禽畜粪便中矿物质组分对其半焦氧化行为的影响[J]. 中国电机工程学报, 2010, 30(26): 113-118. (ZHANG Shou-yu, PENG Ding-mao, WANG Xiu-jun, WANG Jian, GU Li-ying, LIU Yang, DAI Feng. Effect of mineral matters on the oxidation behavior of manure char[J]. Proceeding of the Chinese Society for Electrical Engineering, 2010, 30(26): 113-118.)

杨正虎, 袁益超, 刘聿拯, 曹伟武. 生物质能系统研究及发展[J]. 上海理工大学学报, 2004, 26(1): 35-41. (YANG Zheng-hu, YUAN Yi-cao, LIU Yu-zheng, CAO Wei-wu. Development and research on the biomass energy system[J]. Journal of University of Shanghai for Science and Technology, 2004, 26(1): 35-41.)

赵军, 王述洋. 我国生物质资源与利用[J]. 太阳能学报, 2008, 29(1): 90-94. (ZHAO Jun, WANG Shu-yang. Bio-energy resource and its utilization in China[J]. Acta Energiae Solaris Sinica, 2008, 29(1): 90-94.)

BALAT M, BALAT M, KIRTY E, BALAT H. Main routes for the thermo-conversion of biomass into fuels and chemicals. Part 1: Pyrolysis systems[J]. Energy Convers Manage, 2009, 50(12): 3147-3157.

DEMIRBAS A. Current technologies for the thermo-conversion of biomass into fuels and chemical[J]. Energy Sources, 2004, 26(8): 715-730.

ZHANG L H, XU C B, CHAMPAGNE P. Overview of recent advances in thermo-chemical conversion of biomass[J]. Energy Convers Manage, 2010, 51(5): 969-982.

CHEN Y Q, YAGN H P, WANG X H, ZHANG S H, CHEN H P. Biomass-based pyrolytic polygeneration system on cotton stalk pyrolysis: Influence of temperature[J]. Bioresour Technol, 2012, 107: 411-418.

STREZOV V, PATTERSONA M, ZYMLAB V, FISHERC K, EVANSD T J, NELSONA P F. Fundamental aspects of biomass carbonization[J]. J Anal Appl Pyrolysis, 2007, 79(1/2): 91-100.

陈登宇, 朱锡锋. 生物质热反应机理与活化能确定方法[J]. 燃料化学学报, 2011, 39(9): 670-674. (CHEN Deng-yu, ZHU Xi-feng. Thermal reaction mechanism of biomass and determination of activation energy II. Pyrolysis section[J]. Journal of Fuel Chemistry and Technology, 2011, 39(9): 670-674.)

王贤华, 陈汉平, 张世红, 朱波, 杨海平. 生物质微波干燥及对热解的影响[J]. 燃料化学学报, 2011, 39(1): 14-20. (WANG Xian-hu, CHEN Han-ping, ZHANG Shi-hong, ZHU Bo, YANG Hai-ping. Microwave drying of biomass and its effect on pyrolysis characteristics[J]. Journal of Fuel Chemistry and Technology, 2011, 39(1): 14-20.)

SAIT H H, HUSSAIN A, SALEMA A A, ANI F N. Pyrolysis and combustion kinetics of date palm biomass using thermogravimetric analysis[J]. Bioresour Technol, 2012, 118: 382-389.

刘圣勇, 王艳玲, 白冰, 苏超杰, 杨国锋, 张飞. 玉米秸秆致密成型燃料燃烧动力学分析[J]. 农业工程学报, 2011, 27(9): 287-292. (LIU Sheng-yong, WANG Yan-ling, BAI Bing, SU Chao-jie, YANG Guo-feng, ZHANG Fei. Analysis on combustion kinetics of corn stalk briquetting densification fuel[J]. Transactions of the Chiese Society of Agricultural Engineering, 2011, 27(9): 287-292.)

于广锁, 祝庆瑞, 许慎启, 霍威, 周志杰. 煤及其拔头半焦的燃烧反应特性研究[J]. 燃料化学学报, 2012, 40(5): 513-518. (YU Guang-suo, ZHU Qing-rui, XU Shen-qi, HUO Wei, ZHOU Zhi-jie. Combustion characteristics of coal and coal char from coal topping process[J]. Journal of Fuel Chemistry and Technology, 2012, 40(5): 513-518.)

曹晓哲, 赵卫东, 刘健忠, 孙剑峰, 周俊虎, 岑可法. 煤泥水煤浆燃烧特性的热重研究[J]. 煤炭学报, 2009, 34(10): 1394-1399. (CAO Xiao-zhe, ZHAO Wei-dong, LIU Jian-zhong, SUN Jian-feng, ZHOU Jun-hu, CEN Ke-fa. A thermogravimetry investigation on the combustibility of coalslime water slurry[J]. Journal of China coal society, 2009, 34(10): 1394-1399.)

ZHANG S Y, LU J F, ZHANG J S, YUE G X. Effect of pyrolysis intensity on the reactivity of coal-char[J]. Energy Fuels, 2008, 22(5): 3213-3221.

张守玉, 吕俊复, 朱廷钰, 黎永, 岳光溪. 热处理对煤焦反应性及微观结构的影响[J]. 燃料化学学报, 2004, 32(6): 673-678. (ZHANG Shou-yu, LU Jun-fu, ZHU Ting-yu, LI Yong, YUE Guang-xi. Effect of heat treatment on the reactivity and microstructure of coal-char[J]. Journal of Fuel Chemistry and Technology, 2004, 32(6): 673-678.)

ZHANG S Y, HONG R Y, CAO J P, TAKARADA T. Influence of manure types and pyrolysis conditions on the oxidation behavior of manure char[J]. Bioresour Technol, 2009, 100(18): 4278-4283.

卢洪波, 戴惠玉, 马玉鑫. 生物质三组分燃烧特性及动力学分析[J]. 农业工程学报, 2012, 28(17): 186-191. (LU Hong-bo, DAI Hui-yu, MA Yu-xin. Combustion characteristics and dynamic analysis of three biomass components[J]. Transactions of the Chinese Society of Agricultural Engineering, 2012, 28(17): 186-191.)

葛仕福, 赵培涛, 李杨, 闫伟伟, 陈振乾. 污泥-秸秆衍生固体燃料燃烧特性[J]. 中国电机工程学报, 2012, 32(17): 74-82. (GE Shi-fu, ZHAO Pei-tao, LI Yang, YAN Wei-wei, CHEN Zhen-qian. Combustion characteristics of sewage sludge-straw derived fuel[J]. Proceedings of the Chinese Society for Electrical Engineering, 2012, 32(17): 74-82.)

张守玉, 吕俊复, 黎永, 岳光溪. 煤中矿物质对煤焦氧化的催化性能在热处理过程中的变化[J]. 燃烧科学与技术, 2005, 11(2): 137-141. (ZHANG Shou-yu, LU Jun-fu, LI Yong, YUE Guang-xi. Transition of the Catalytic Capability of Minerals for the Oxidation of Coal-Char During Heat Treatment[J]. Journal of Combustion Science and Technology, 2005, 11(2): 137-141.)

葛庆仁. 气固反应动力学[M]. 北京:原子能出版社, 1991: 273-281. (GE Qing-ren. Kinetics of gas-solid reaction [M]. Beijing: Atomic Energy Press, 1991: 273-281.)

何必繁, 王里奥, 黄川. 重庆城市污泥燃烧机动力学特性分析[J]. 中国电机工程学报, 2010, 30(35): 32-37. (HE Bi-fan, WANG Li-ao, HUANG Chuan. Study on combustion characteristics and kinetics of Chongqing municipal sewage sludge[J]. Proceedings of the Chinese Society for Electrical Engineering, 2010, 30(35): 32-37.

张守玉, 黎永, 吕俊复, 岳光溪, 王洋. 煤焦反应活性影响因素的探讨[J]. 煤炭转化, 2003, 26(2): 25-28. (ZHANG Shou-yu, LI Yong, LU Jun-fu, YUE Guang-xi, WANG Yang. Discussion on the effect of heating treatment on the intrinsic reactivity of coal-char[J]. Journal of Combustion Science and Technology, 2003, 26(2): 25-28.)

施引文献

资源附件(0)

访问统计