Hydrogen making from steam-carbon reaction catalyzed by K2CO3 with light irradiation heating
-
摘要: 在氙灯模拟的太阳光聚光反应系统上,以K2CO3作为催化剂进行了700~720 ℃条件下的水-碳低温催化制氢实验。结果表明,催化作用下的产氢速率是未添加催化剂时的10倍,催化剂添加量在10%~20%时反应产氢率没有本质的区别。具体分析了K2CO3催化水-碳制氢反应的氧转移机理,并用该机理对反应产物中出现的氢、氧不平衡现象做出了解释。实验中,光能转换化为化学能的效率达到13.12%,优于光伏法制氢效率10.85%。最后对进一步提高能量转换效率提出了可参考的思路。Abstract: With the simulated solar reaction system irradiated by Xenon lamp, an experiment of hydrogen making from steam-carbon reaction catalyzed by K2CO3 was carried out at about 700 ℃. It is found that the rate of hydrogen production with catalysts is 10 times more than that without catalysts, and there is no obvious difference in the rate of hydrogen production with the catalyst content from 10% to 20%. The oxygen-transfer mechanism for hydrogen making from steam-carbon reaction catalyzed by K2CO3 was discussed in detail, which was used to explain the unbalanced phenomenon of hydrogen and oxygen in reaction product. The efficiency of light energy conversion to chemical energy reaches to 13.12% in the experiment, which is better than that of photovoltaic method(10.85%). Some approaches for improving the energy conversion efficiency were proposed.
-
STEINFELD A, WEIMER A W. Thermochemical production of fuels with concentrated solar energy[J]. Opt Express, 2010, 18(S1): A100-A111. ROMERO MANUEL, STEINFELD ALDO. Concentrating solar thermal power and thermochemical fuels[J]. Energy Environ Sci, 2012, 5(11): 9234-9245. SMESTAD G P, STEINFELD A. Review: Photochemical and thermochemical production of solar fuels from H2O and CO2 using metal oxide catalysts[J]. Ind Eng Chem Res, 2012, 51(37): 11828-11840. 王宝辉, 吴红军, 刘淑芝, 盖翠萍. 太阳能分解水制氢技术研究进展[J]. 化工进展, 2006, 25(7): 733-738. (WANG Bao-hui, WU Hong-jun, LIU Shu-zhi, GAI Cui-ping. Advance on research of hydrogen production by solar water splitting[J]. Chemical Industry and Engineering Progress, 2006, 25(7): 733-738.) TRIBUTSCH H. Photovoltaic hydrogen generation[J]. Int J Hydrogen Energy, 2008, 33(21): 5911-5930. XIAO L, WU S Y, LI Y R. Advances in solar hydrogen production via two-step water-splitting thermochemical cycles based on metal redox reactions[J]. Renewable Energy, 2012, 41: 1-12. STAMATIOU A, LOUTZENHISER P G, STEINFELD A. Solar syngas production via H2O/CO2-splitting thermochemical cycles with Zn/ZnO and FeO/Fe3O4 redox reactions[J]. Chem Mater, 2010, 22(3): 851-859. 祝星, 王华, 魏永刚, 李孔斋, 晏冬霞. 金属氧化物两步法化学循环分解水制氢化学进[J]. 2010, 22(5): 1010-1020. (ZHU Xing, WANG Hua, WEI Yong-gang, LI Kong-zhai, YAN Dong-xia. Hydrogen production by two-step water-splitting thermochemical cycle based on metal oxide redox System[J]. Progress in Chemistry, 2010, 22(5): 1010-1020.) NOBUYUKI G, TETSURO M, NOBUYUKI K, TATSUYA K. Thermochemical two-step water splitting by internally circulating fluidized bed of NiFe2O4 particles: Successive reaction of thermal-reduction and water-decomposition steps[J]. Int J Hydrogen Energy, 2011, 36(8): 4757-4767. WORNER A, TAMME R. CO2 reforming of methane in a solar driven volumetric receiver-reactor[J]. Catal Today, 1998, 46(2): 165-174. BUCK R, MUIR J F, HOGAN RE.Carbon dioxide reforming of methane in a solar volumetric receiver/reactor: The CAESAR project[J]. Sol Energy Mater, 1991, 24(1): 449-463. MUIR J, HOGAN R, SKOCYPEC R, BUCK R. Solar reforming of methane in a direct absorption catalytic reactor on a parabolic dish: I-Test and analysis[J]. Solar Energy, 1994, 52(6): 467-477. KODAMA T, KIYAMA A. Solar methane reforming using a new type of catalytically-activated metallic foam absorber[J]. J Sol Energy Eng, 2004, 126(2): 808-811. BERMAN A, KARN R K, EPSTEIN M. A new catalyst system for high-temperature solar reforming of methane[J]. Energy Fuels, 2006, 20(2): 455-462. WANG J, SAKANISHI K, SAITO I. High-yield hydrogen production by steam gasification of hypercoal (ash-free coal extract) with potassium carbonate:Comparison with raw coal[J]. Energy Fuels, 2005, 19(5): 2114-2120. 金会心, 王华. 聚光太阳能加热昭通褐煤的气化试验研究[J]. 燃料化学学报, 2001, 29(6): 548-551. (JIN Hui-xin, WANG Hua. Gasification of Zhao tong Lignite Heated by Concentrated Solar Energy[J]. Journal of Fuel Chemistry and Technology, 2001, 29(6): 548-551.) WANG J, JIANG M Q, YAO Y H, ZHANG Y M, CAO J Q. Steam gasification of coal char catalyzed by K2CO3 for enhanced production of hydrogen with out formation of methane[J]. Fuel, 2009, 88(9): 1572-1579. MOULIJN J A, KAPTEIJN F. Towards a unified theory of reactions of carbon with oxygen-containing molecules[J]. Carbon, 1995, 33(8): 1155-1165. 孙雪莲, 王黎, 张占涛. 煤气化复合催化剂研究及机理探讨[J]. 煤炭转化, 2006, 29(1): 15-18. (SUN Xue-lian, WANG Li, ZHANG Zhan-tao. Study on compound catalyst for gasification and its mechanism[J]. Coal conversion, 2006, 29(1): 15-18.) 郝西维, 王黎, 吴嘉州. 煤温和气化技术研究进展[J]. 煤炭转化, 2008, 31(2): 83-89. (HAO Xi-wei, WANG Li, WU Jia-zhou. Progress of research on coal mild gasification[J]. Coal conversion, 2008, 31(2): 83-89.) 徐秀峰, 顾永达, 陈诵英. 煤焦气化反应的影响因素和反应机理的研究进展[J]. 煤炭转化, 1996, 19(2): 48-53. (XU Xiu-feng, GU Yong-da, CHEN Song-ying. The study of influential factors to char gasification reaction and mechanism[J]. Coal conversion, 1996, 19(2): 48-53.)
点击查看大图
计量
- 文章访问数: 1361
- HTML全文浏览量: 20
- PDF下载量: 902
- 被引次数: 0