负载碳酸钾煤焦上CO甲烷化反应的研究

樊利霞; 李克忠; 张荣; 毕继诚

负载碳酸钾煤焦上CO甲烷化反应的研究

樊利霞^1,2,
李克忠^1,3,
张荣^1,,
毕继诚^1,3

1.
中国科学院山西煤炭化学研究所煤转化国家重点实验室, 山西太原 030001;
2.
中国科学院大学, 北京 100049;
3.
新奥集团煤基低碳能源国家重点实验室, 河北廊坊 065001

基金项目: 国家重点基础研究发展规划（973计划，2011CB201305）；国家科技支撑计划（2009BAA25B02）。

详细信息

通讯作者:
张荣，Tel：0351-4151519，E-mail：zrbd@sxicc.ac.cn。

中图分类号: TQ546.2
计量
- 文章访问数: 669
- HTML全文浏览量: 20
- PDF下载量: 653
- 被引次数: 0
出版历程
- 收稿日期: 2014-04-18
- 修回日期: 2014-06-11
- 刊出日期: 2014-09-30

Methanation of CO over coal char loaded with K₂CO₃

1.
State Key Laboratory of Coal Conversion, Institute of Coal Chemistry, Chinese Academy of Sciences, Taiyuan 030001, China;
2.
University of Chinese Academy of Sciences, Beijing 100049, China;
3.
ENN Group State Key Laboratory of Coal-based Low Carbon Energy, Langfang 065001, China

摘要

摘要: 在加压固定床反应器中，考察了负载碳酸钾的府谷煤热解半焦和不同气化率的部分气化半焦对CO甲烷化反应的催化性能。结果表明，原煤热解半焦和脱灰煤热解半焦的甲烷化活性都很低，而负载10%（质量分数）碳酸钾的热解半焦甲烷化活性明显提高，甲烷收率可达30%。负载碳酸钾的热解半焦水蒸气气化反应速率与碳气化率呈“火山”型关系曲线，在碳气化率为22%时达到极大值。在气化反应速率较高时得到的部分气化半焦上，甲烷化反应速率较低。利用红外光谱对半焦官能团进行分析，发现在热解过程中，碳酸钾和煤发生反应形成C-O-K复合物，在1 100 cm^-1附近出现特征振动峰，该峰的强度与碳气化反应速率成正比。不同气化率半焦经过甲烷化反应后，红外光谱谱图中C-O-K峰强度不同程度增大。
- 甲烷化 /
- 碳酸钾 /
- 煤焦 /
- 部分气化
Abstract: The catalytic performance of coal char loaded with potassium carbonate on the CO methanation reaction was investigated in a pressurized fixed bed reactor. The results show that the catalytic activities of raw coal pyrolysis char and demineralized coal pyrolysis char are very low, while with loading 10% potassium carbonate, the catalytic activity of chars increases obviously and the yield of methane reaches to 30%. The gasification rate changes with the progress of carbon conversion and has a maximum value at a carbon conversion around 22%. The analysis by FT-IR indicates that the interaction of potassium carbonate with coal can form C-O-K complexes during pyrolysis at 700℃, with an infrared band around 1 100 cm^-1. The intensity of this band is found to be proportional to the steam gasification rate of the carbon. After reaction in CO-H₂ mixture gas at 700℃ for 180 min, the intensity of C-O-K vibration increases more or less.
- methanation /
- potassium carbonate /
- pyrolysis char /
- partially gasified char

HTML全文

参考文献(14)

王明华, 李政, 麻林巍. 坑口煤制代用天然气的技术经济性分析及发展路线构思[J]. 现代化工, 2008, 28(3): 13-16. (WANG Ming-hua, LI Zheng, MA Lin-wei. Technical and economic analysis on pithead coal to substitute natural gas system and its developing route in China[J]. Modern Chemical Industry, 2008, 28(3): 13-16.)

HIRSCH R L, GALLAGHER J E, LESSARD R R, WESELHOFT R D. Catalytic coal gasification: An emerging technology[J]. Science, 1982, 215(4529): 121-127.

MIMS C A, CHLUDZINSKI JR J J, PABST J K, BAKER R T K. Potassium-catalyzed gasification of graphite in oxygen and steam[J]. J Catal, 1984, 88(1): 97-106.

KARIMI A, GRAY M R. Effectiveness and mobility of catalysts for gasification of bitumen coke[J]. Fuel, 2011, 90(1): 120-125.

WANG J, JIANG M Q, YAO Y H, ZHANG Y M, CAO J Q. Steam gasification of coal char catalyzed by K₂CO₃ for enhanced production of hydrogen without formation of methane[J]. Fuel, 2009, 88(9): 1572-1579.

OTAKE T, TONE S, KIMURA S, HINO Y. Methane formation over potassium carbonate catalyst loaded on coal char[J]. J Chem Eng Jpn, 1984, 17(5): 503-508.

MEIJER R, VAN DOORN R, KAPTEIJN F, MOULIJN J A. Methane formation in H₂, CO mixtures over carbon-supported potassium carbonate[J]. J Catal, 1992, 134(2): 525-535.

MIMS C A, KRAJEWSKI J J. Mechanism of methane formation in potassium catalyzed carbon gasification[J]. J Catal, 1986, 102(1): 140-150.

鲍卫仁, 常丽萍, 谢克昌. 酸洗脱灰对原煤样品性能的影响研究[J]. 太原理工大学学报, 2000, 31(4): 354-357. (BAO Wei-ren, CHANG Li-ping, XIE Ke-chang. Effects of acid washing methods on the characteristics of raw coal[J]. Journal of Taiyuan University of Technology, 2000, 31(4): 354-357.)

YUH S J, WOLF E E. FTIR studies of potassium catalyst-treated gasified coal chars and carbons[J]. Fuel, 1983, 62(2): 252-255.

FRERIKS I L C, VAN WECHEM H M H, STUIVER J C M, BOUWMAN R. Potassium-catalysed gasification of carbon with steam: A temperature-programmed desorption and Fourier transform infrared study[J]. Fuel, 1981, 60(6): 463-470.

KOPYSCINSKI J, RAHMAN M, GUPTA R, MIMS C A, HILL J M. K₂CO₃ catalyzed CO₂ gasification of ash-free coal. Interactions of the catalyst with carbon in N₂ and CO₂ atmosphere[J]. Fuel, 2014, 117(B): 1181-1189.

张报安, 黄河, 金玳. 用红外光谱考察活性炭上表面物种的气化性能[J]. 燃料化学学报, 1986, 14(3): 274-277. (ZHANG Bao-an, HUANG He, JIN Dai. A FTIR study on gasification performance of carbon surface species[J].Journal of Fuel Chemistry and Technology, 1986, 14(3): 274-277.)

HASHIMOTO K, MIURA K, XU J J, WATANABE A, MASUKAMI H. Relation between the gasification rate of carbons supporting alkali metal salts and the amount of oxygen trapped by the metal[J]. Fuel, 1986, 65(4): 489-494.

施引文献

资源附件(0)

访问统计