Online catalytic cracking of bio-oil over HZSM-5 zeolite and analysis of catalyst deactivation
-
摘要: 对不同使用时间的HZSM-5分子筛在线催化提质制取的生物油进行理化特性和成分分析,从生物油品质角度对HZSM-5的催化性能进行评价;并采用TG、BET、XRD、SEM和TEM等方法对失活的HZSM-5催化剂进行表征分析,探讨了HZSM-5催化提质生物油的失活机理,并进行再生研究。研究表明,HZSM-5分子筛可转化生物油中的酸类、醛类和酮类等"非期望"有机物,生成较多"期望"有机物,如酚类和芳烃类物质,降低生物油的氧含量及酸性,提高生物油的热值;HZSM-5使用80 min后,生物油品质明显变差,催化剂活性明显降低;失活催化剂上沉积的焦炭主要呈纤维状,同时,还存在少量石墨状焦炭,焦炭总量达14.12%,且使用过程中催化剂的比表面积和孔容均下降,晶粒的团聚现象加剧,结晶度下降;在催化提质过程中,在孔道内生成的石墨状焦炭及在表面形成的纤维状焦炭大量覆盖活性位点,使得催化剂失活。经550℃再生后,催化剂可恢复催化性能。Abstract: The online catalytic cracking of bio-oil over HZSM-5 was investigated. The HZSM-5 catalyst samples used for different reaction times were analyzed in terms of physicochemical properties and chemical compositions to investigate the effects of bio-oil catalytic online cracking. Simultaneously, the used HZSM-5 catalysts were analyzed by TG, BET, XRD, SEM and TEM to explore the mechanism of HZSM-5 catalyst deactivation. The regeneration of the deactivated catalyst was also studied. It was found that acids, aldehydes and ketones as the undesirable organics contained in the bio-oil were reduced by deoxidization over HZSM-5 and more desirable organics like phenols and aromatic hydrocarbons could be produced. Meanwhile, the activity of the catalyst declined after 80 min reaction, leading to the worse quality of the refined bio-oil. The coke deposited was mainly fibrous carbon with a little graphite carbon, where the total amount of the coke was 14.12%. The graphite coke deposited inside the pore of the catalyst and the fibrous coke deposited outside the surface of the catalyst were contributed to the deactivation of the catalyst. The basic structure of the catalyst remained unchanged, but the specific area and pore volume of the catalyst were decreased simultaneously and the agglomeration of grain was increased, leading to the decrease of crystallinity. The change of some crystal structure of the catalyst resulted in the deactivation of catalyst. After the regeneration, the catalytic activity could be recoveried.
-
Key words:
- HZSM-5 /
- online upgrading /
- bio-oil /
- deactivation mechanism
-
徐莹, 王铁军, 马隆龙, 张琦, 陈冠益. 真空热解松木粉制备生物油[J]. 农业工程学报, 2013, 29(1): 196-201. (XU Ying, WANG Tie-jun, MA Long-long, ZHANG Qi, CHEN Guan-yi. Technology of bio-oil preparation by vacuum pyrolysis of pine straw[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2013, 29(1): 196-201.) FAN Y S, CAI Y X, LI X H, YIN H Y, YU N. Rape straw as a source of bio-oil via vacuum pyrolysis: Optimization of bio-oil yield using orthogonal design method and characterization of bio-oil[J]. J Anal Appl Pyrolysis, 2014, 106: 63-70. VAMVUKA D. Bio-oil, soild and gaseous biofuels from biomass pyrolysis processes-An overview[J]. Int J Energy Res, 2011, 35(10): 835-862. MORTENSEN P M, GRUNWALDT J -D, JENSEN P A, KNUDSEN K G, JENSEN A D. A review of catalytic upgrading of bio-oil to engine fuels[J]. Appl Catal A: Gen, 2011, 407(1/2): 1-19. 蒋恩臣, 赵创, 王明峰, 熊磊明. HZSM-5催化提质焦油燃烧特性研究[J]. 农业机械学报, 2013, 44(S1): 138-142. (JIANG En-cheng, ZHAO Chuang, WANG Ming-feng, XIONG Lei-ming. Combustion characteristic of bio-tar by HZSM-5 catalytic upgrading[J]. Transactions of the Chinese Society for Agricultural Machinery, 2013, 44(S1): 138-142.) AHO A, KUMAR N, LASHKUL A V, ERÄNEN K, ZIOLEK M, DECYK P, SALMI T, HOLMBOM B, HUPA M, MURZIN D Y. Catalytic upgrading of woody biomass derived pyrolysis vapours over iron modified zeolites in a dual-fluidized bed reactor[J]. Fuel, 2010, 89(8): 1992-2000. ILIOPOULOU E F, STEFANIDIS S D, KALOGIANNIS K G, DELIMITIS A, LAPPAS A A, TRIANTAFYLLIDIS K S. Catalytic upgrading of biomass pyrolysis vapors using transition metal-modified ZSM-5 zeolite[J]. Appl Catal B: Environ, 2012, 127: 281-290. 周志恒, 范天博, 刘云义, 高红. Zn/HZSM-5分子筛气固相循环法合成苯基二氯化膦[J]. 石油学报(石油加工), 2012, 28 (S1): 116-121. (ZHOU Zhi-heng, FAN Tian-bo, LIU Yun-yi, GAO Hong. Synthesis of dichlorophenylphosphine over the catalyst Zn/HZSM-5 in the gas phase[J]. Acta Petrolei Sinica (Petoleum Processing Section), 2012, 28 (S1): 116-121.) 魏巍, 陈平, 楼辉, 郑小明. HZSM-5催化剂上超临界乙醇中生物油催化提质及检测方法研究[J]. 浙江大学学报(理学版), 2012, 39(1): 67-70. (WEI Wei, CHEN Ping, LOU Hui, ZHENG Xiao-ming. Study on Bio-oil upgrading reaction using HZSM-5 under super-critical ethanol and analysis method[J]. Journal of Zhenjiang University (Science Edition), 2012, 39(1): 67-70.) LEE K Y, KANG M Y, IHM S K. Deactivation by coke deposition on the HZSM-5 catalysts in the methanol-to-hydrocarbon conversion[J]. J Phys Chem Solids, 2012, 73(12): 1542-1545. 李洪宇, 颜涌捷, 任铮伟, 李庭琛. 在线催化裂解精制生物质裂解油[J].太阳能学报, 2008, 29(5): 515-519. (LI Hong-yu, YAN Yong-jie, REN Zheng-wei, LI Ting-chen. The progress of the online upgrading bio-oil pyrolzed from biomass[J]. Acta Energiae Solaris Sinica, 2008, 29(5): 515-519.) 郑志锋, 陈冲, 黄元波, 蒋剑春, 薛秋. HZSM-5催化纤维素液化的研究[J]. 太阳能学报, 2011, 32(3): 379-382. (ZHENG Zhi-feng, CHEN Chong, HUANG Yuan-bo, JIANG Jian-chun, XUE Qiu. Study on liquefaction of cellulose by using HZSM-5 as catalyst[J]. Acta Energiae Solaris Sinica, 2011, 32(3): 379-382.) 郭春垒, 方向晨, 贾立明, 刘全杰. 分子筛重整催化剂Pt/HZSM-5积碳失活研究[J]. 石油炼制与化工, 2012, 43(4): 25-29. (GUO Chun-lei, FANG Xiang-chen, JIA Li-ming, LIU Quan-jie. Study on the deactivation of Pt/HZSM-5 zeolitic reforming catalyst by coke deposition[J]. Petroleum Processing and Petrochemicals, 2012, 43(4): 25-29.) SERRANO D P, AGUADO J, RODRÍGUEZ J M, PERAL A. Catalytic cracking of polyethylene over nanocrystalline HZSM-5: Catalyst deactivation and regeneration study[J]. J Anal Appl Pyrolysis, 2007, 79(1/2): 456-464. REDDY K S K, SREEDHAR I, RAGHAVAN K V. Kinetic studies on vapour phase pyridine synthesis and catalyst regeneration studies[J]. Can J Chem Eng, 2011, 89(4): 854-862. ELORDI G, OLAZAR M, LOPEZ G, CASTAÑO P, BILBAO J. Role of pore structure in the deactivation of zeolites (HZSM-5, Hβ and HY) by coke in the pyrolysis of polyethylene in a conical spouted bed reactor[J]. Appl Catal B: Environ, 2011, 102(1/2): 224-231. IBÁÑEZ M, VALLE B, BILBAO J, GAYUBO A G, CASTAÑO P. Effect of operating conditions on the coke nature and HZSM-5 catalysts deactivation in the transformation of crude bio-oil into hydrocarbons[J]. Catal Today, 2012, 195(1): 106-113. BEATRIZ V, CASTAÑO P, OLAZAR M, BILBAO J, GAYUBO A G. Deactivating species in the transformation of crude bio-oil with methanol into hydrocarbons on a HZSM-5 catalyst[J]. J Catal, 2012, 285(1): 304-314. GAYUBO A G, AGUAYO A T, ATUTXA A, PRIETO R, BILBAO J. Deactivation of a HZSM-5 zeolite catalyst in the transformation of the aqueous fraction of biomass pyrolysis oil into hydrocarbons[J]. Energy Fuels, 2004, 18(6): 1640-1647. LLIAS S, BHAN A. Tuning the selectivity of methanol-to-hydrocarbons conversion on H-ZSM-5 by co-processing olefin or aromatic compounds[J]. J Catal, 2012, 290: 186-192.
点击查看大图
计量
- 文章访问数: 1012
- HTML全文浏览量: 33
- PDF下载量: 512
- 被引次数: 0