微型流化床反应分析仪中原位/非原位煤焦气化动力学研究

王芳; 曾玺; 王永刚; 余剑; 许光文

微型流化床反应分析仪中原位/非原位煤焦气化动力学研究

1.
中国矿业大学(北京) 化学与环境工程学院, 北京 100083;
2.
中国科学院过程工程研究所多相复杂系统国家重点实验室, 北京 100190

基金项目: 国家自然科学基金(21306209);科技部重大仪器专项(2011YQ120039);中国科学院战略性先导科技专项"低阶煤清洁高效梯级利用关键技术与示范"(XDA07050400)。

详细信息

通讯作者:
许光文, Tel:010-82544886, E-mail:gwxu@ipe.ac.cn;曾玺, E-mail:xzeng@ipe.ac.cn。

中图分类号: TQ523.2
计量
- 文章访问数: 404
- HTML全文浏览量: 16
- PDF下载量: 369
- 被引次数: 0
出版历程
- 收稿日期: 2014-11-20
- 刊出日期: 2015-04-30

Investigation on in/ex-situ coal char gasification kinetics in a micro fluidized bed reactor

1.
School of Chemical and Environmental Engineering, China University of Mining & Technology(Beijing), Beijing 100083, China;
2.
State Key Laboratory of Multi-phase Complex Systems, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, China

摘要

摘要: 利用新开发的微型流化床反应分析仪(micro-fluidized bed reaction analysis, MFBRA) 考察了义马烟煤半焦的原位以及两种非原位半焦气化行为并测定了其动力学参数,其中,原位半焦气化是指煤热解温度和气氛与半焦气化过程一致,非原位半焦1气化是指煤在Ar气氛下热解,热态条件下直接在CO₂气氛下气化;非原位半焦2气化是指煤在Ar气氛下热解,冷却收集后再在CO₂气氛下气化。研究发现,原位半焦具有最大的比表面积和最小的平均孔径,石墨化程度最弱,且对CO₂的化学吸附能力最强,表面活性位点最多。在最小化气体扩散的实验条件下,原位半焦气化反应的反应速率明显比非原位半焦气化反应快,且求取的活化能数据较小。实验揭示了原位半焦和非原位半焦结构和反应性的差异,也证明了MFBRA对原位等温气化反应的适用性。
- 微型流化床 /
- 原位气化 /
- 非原位气化 /
- 反应动力学 /
- 等温反应
Abstract: In-situ char and ex-situ char gasification characteristic was studied by using a newly developed micro fluidized bed reaction analyzer (MFBRA) and the reaction kinetics parameters were obtained. The in-situ char gasification proceeds using the same atmosphere, temperature and reactor in the gasification following the pyrolysis; the ex-situ char 1 gasification is defined as coal pyrolysis in Ar atmosphere and then gasification at hot state in the same reactor; and ex-situ char 2 gasification reaction is defined as coal pyrolysis in Ar atmosphere and then gasification after thermal annealing. By analyzing the three kinds of char, it can be seen that in-situ char has the largest specific surface area, lowest graphitization degree, and strongest sorption ability for CO₂. Under the minimized limitations of heat and mass transfer, in-situ char gasification has the highest reaction rate, and lowest reaction energy. The study also proves the reliability of MFBRA for in-situ char gasification reaction.
- MFBRA /
- in-situ gasification /
- ex-situ gasification /
- reaction kinetics /
- isothermal reaction

HTML全文

参考文献(31)

XIAO R, ZHANG M Y, JIN B S. High-temperature air/steam-blown gasification of coal in a pressurized spout-fluid bed[J]. Energy Fuels, 2006, 20(2):715-720.

任海君, 张永奇, 房倚天, 黄戒介, 汪洋. 褐煤焦中的矿物质对气化动力学的影响[J]. 化学工程, 2010, 38(10):132-135. (REN Hai-jun, ZHANG Yong-qi, FANG Yi-tian, HUANG Jie-jie, WANG Yang. Effect of minerals in lignite char on kinetics of steam gasification[J]. Chem Eng, 2010, 38(10):132-135.)

周静, 周志杰, 龚欣, 于遵宏. 煤焦二氧化碳气化动力学研究(I)等温热重法[J]. 煤炭转化, 2002, 25(4):66-69. (ZHOU Jing, ZHOU Zhi-Jie, GONG Xin, YU Zun-hong. Study of char-CO₂ gasification:(I) By isothermal thermogravimetry[J]. Coal Convers, 2002, 25(4):66-69.)

POOYA L, ZAINAL A Z, ABSUA R M, MAEDEH M. CO₂ gasification reactivity of biomass char:Catalytic influence of alkali, alkaline earth and transition metal salts[J]. Bioresour Technol, 2013, 144:288-295.

SUPAPORN S, KUNCHANA B, BOONYARACH K. CO₂ gasification of Thai coal chars:Kinetics and reactivity studies[J]. Korean J Chem Eng, 2010, 39(5):46-53.

HYO J J, SANG S P, JUNGHO H. Co-gasification of coal-biomass blended char with CO₂ at temperatures of 900-1 100 ℃[J]. Fuel, 2014, 116:465-470.

刘殊远, 汪印, 武荣成, 曾玺, 许光文. 热态半焦和冷态半焦催化裂解煤焦油研究[J]. 燃料化学学报, 2013, 41(9):1041-1049. (LIU Shu-yuan, WANG Yin, WU Rong-cheng, ZENG Xi, XU Guang-wen. Research on coal tar catalytic cracking over hot in-situ chars[J]. J Fuel Chem Technol, 2013, 41(9):1041-1049.)

ZENG X, WANG Y, YU J. Coal pyrolysis in a fluidized bed for adapting to a two-stage gasification process[J]. Energy Fuels, 2011, 25(3):1092-1098.

向银花, 王洋, 张建民, 张守玉, 房倚天, 董众兵. 部分气化焦的水蒸气气化动力学[J]. 化工学报, 2003, 54(3):368-373. (XIANG Yin-hua, WANG Yang, ZHANG Jian-min, ZHANG Shou-yu, FANG Yi-tian, DONG Zhong-bing. Kinetic on steam gasification of partially gasified char[J]. CIESC J, 2003, 54(3):368-373.)

杨小风, 周静, 龚欣, 于遵宏. 煤焦水蒸气气化特性及动力学研究[J]. 煤炭转化, 2003, 26(4):46-50. (YANGXiao-feng, ZHOU Jing, GONG Xin, YU Zun-hong. Kinetic and characteristic study of char-H₂O gasification by isothermal thermogravimetry[J]. Coal Convers, 2003, 26(4):46-50.)

张林仙, 黄戒介, 房倚天, 王洋. 中国无烟煤焦气化活性的研究-水蒸气与二氧化碳气化活性的比较[J]. 燃料化学学报, 2006, 34(3):265-269. (ZAHNG Lin-xian, HUANG Jie-jie, FANG Yi-tian, WANG Yang. Study on reactivity of Chinese anthracite chars gasification:Comparison of reactivity between steam and CO₂ gasification[J]. J Fuel Chem Technol, 2006, 34(3):265-269.)

YU J, YUE J R, XU G W, SUN L X. Kinetics and mechanism of solid reactions in a micro fluidized bed reactor[J]. AIChE J, 2010, 56(11):2905-2912.

YU J, ZENG X, ZHANG J W, ZHONG M, ZHANG G Y, WANG Y, XU G W. Isothermal differential characteristics of gas-solid reaction in micro-fluidized bed reactor[J]. Fuel, 2013, 103:29-36.

YU J, ZENG X, ZHANG J W, ZHONG M, ZHANG G Y, WANG Y, XU G W. Kinetics and mechanism of direct reaction between CO₂ and Ca(OH)₂ in micro fluidized bed[J]. Sci Techonl, 2013, 47(13):7514-7520.

ZENG X, WANG W, WANG Y G, YU J, XU G W. Characterization of char gasification in a micro fluidized bed reaction analyzer[J]. Energy Fuels, 2014, 28(3):1838-1845.

ZHAO Z G, ZHANG J W, ZHANG G Y, ZENG X, ZHAO F X, XU G W. Pilot study on jetting pre-oxidation fluidized bed gasification adapting to caking coal[J]. Appl Energy, 2013, 110:276-284.

季颖, 曾玺, 余剑, 岳君容, 李奡明, 许光文. 微型流化床反应分析仪中煤半焦水蒸气气化反应特性[J]. 化工学报, 2014, 65(9):3447-3456. (JI Ying, ZENG Xi, YU Jian, YUE Jun-rong, LI Ao-ming, XU Guang-wen. Steam gasification characteristics of coal char in micro-fluidized bed reaction analyzer[J]. CIESC J, 2014, 65(9):3447-3456.)

MOLINA A, MONTAYO A, MONDRAGN F. CO₂ strong chemisorption as an estimate of coal char gasification reactivity[J]. Fuel, 1999, 78(8):971-977.

XU K, HU S, SU S, XU C F, SUN L S, CHAO S, JIANG L, XIANG J. Study on char surface active sites and their relationship to gasification reactivity[J]. Energy Fuels, 2012, 27(1):118-125.

刘忠锁, 汪琦, 邹宗树, 谭广雷. 非等温热重分析研究碳气化动力学[J]. 材料与冶金学报, 2010, 9(1):68-71. (LIU Zhong-suo, WANG qi, ZOU Zong-shu, TAN Guang-lei. Study on carbon gasification kinetics using non-isothermal thermogravimetric analysis[J]. J Mater Metall, 2010, 9(1):68-71.)

GUIZANI C, ESCUDEROSANZ F J, SALVADOR S. Effects of CO₂ on biomass fast pyrolysis:Reaction rate, gas yields and char reactive properties[J]. Fuel, 2014, 116:310-320.

QIAN L, ZHAO Y J, SUN S Z, CHEN H W, CHEN H, WANG D. Chemical/physical properties of char during devolatilization in inert and reducing conditions[J]. Fuel Process Technol, 2014, 118:327-334.

SENNECA O, SALATINO P, MASI S. Heat treatment-induced loss of combustion reactivity of a coalchar:The effect of exposure to oxygen[J]. Exp Therm Fluid Sci, 2004, 28(7):735-741.

李庆钊, 林柏泉, 赵长遂, 武卫芳. 基于傅里叶红外光谱的高温煤焦表面化学结构特性分析[J]. 中国电机工程学报, 2011, 31(32):46-52. (LI Qing-zhao, LIN Bai-quan, ZHAO Chang-sui, WU Wei-fang. Chemical structure analysis of coal char surface based on Fourier-transform infrared spectrometer[J]. Proc CSEE, 2011, 31(32):46-52.)

WATANABE H, SHIMOMURA K, OKAZAKI K. Effect of high CO₂ concentration on char formation through mineral reaction during biomass pyrolysis[J]. Proc Combust Ins, 2013, 34(2):2339-2345.

罗陨飞, 李文华. 中低变质程度煤显微组分大分子结构的XRD研究[J]. 煤炭学报, 2004, 29(31):338-341. (LUO Yun-fei, LI Wen-hua. X-ray diffraction analysis on the different macerals of several low-to-medium metamorpic grade coals[J]. J China Coal Soc, 2004, 29(31):338-341.)

王丽, 张蓬洲. 煤的RXD的结构分析[J]. 煤炭转化, 1997, 20(1):68-71. (WANG Li, ZHANG Peng-zhou. XRD study of coal structure[J]. Coal Convers, 1997, 20(1):68-71.)

MIURA K, HANSHIMOTO K, SILVESTON P L. Factors affecting the reactivity of coal chars during gasification, and indices representing reactivity[J]. Fuel, 1989, 68(11):1461-1475.

PENG F F, LEE I C, YANG R Y K. Reactivities of in situ and ex situ coal chars during gasification in steam at 1 000-1 400 ℃[J]. Fuel Process Technol, 1995, 41(3):233-251.

SADHUKHAN A K, GUPTA P, SAHA R K. Analysis of the dynamics of coal char combustion with Ignition and extinction phenomena:Shrinking core model[J]. Int J Chem Kinet, 2008, 40(9):569-582.

ZHANG L X, HUANG J J, FANG Y T, WANG Y. Gasification reactivity and kinetics of typical chinese anthracite chars with steam and CO₂[J]. Energy Fuels, 2006, 20(3):1201-1210.

施引文献

资源附件(0)

访问统计