准东煤掺烧高岭土对固钠率及灰熔融特性影响研究

沈铭科; 邱坤赞; 黄镇宇; 王智化; 刘建忠

准东煤掺烧高岭土对固钠率及灰熔融特性影响研究

浙江大学能源清洁利用国家重点实验室热能工程研究所, 浙江杭州 310027

基金项目: 国家重点基础研究发展规划(973计划, 2012CB214906)。

详细信息

通讯作者:
邱坤赞,E-mail:qiukz@zju.edu.cn。

中图分类号: TQ534
计量
- 文章访问数: 498
- HTML全文浏览量: 26
- PDF下载量: 530
- 被引次数: 0
出版历程
- 收稿日期: 2015-04-12
- 修回日期: 2015-07-03
- 刊出日期: 2015-09-30

Influence of kaolin on sodium retention and ash fusion characteristic during combustion of Zhundong coal

State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China

摘要

摘要: 选择常见的黏土矿物高岭土作为准东煤添加剂掺烧,研究了不同掺混比例、不同燃烧温度下添加剂的固钠率和煤灰熔融特性的变化,结合XRD谱图和三元相图研究了灰中矿物在高温下的演变过程。结果表明,固钠率随高岭土掺混比例增加逐渐增大,在0~2%时增长较快,2%~5%增长较慢,随燃烧温度升高略微下降;掺混后煤灰熔点随掺混比例先缓慢减小,再快速减小,后快速增加,在3%时达到1 200 ℃左右;XRD和三元相图分析结果表明,煤灰熔融特性变化是由于灰中硅钙石、钙黄长石和钙长石矿物比例的变化引起,发生低温共熔现象是导致掺混比例为3%和4%时煤灰熔点最低的主要原因;当掺混比例为2%时,固钠率在60%以上且灰熔点在1 300 ℃左右,利于固态排渣,当掺混比例为3.0%~4.0%时,灰熔点在1 200 ℃左右,利于液体排渣。
- 准东煤 /
- 高岭土 /
- 固钠率 /
- 灰熔融特性 /
- 低温共熔
Abstract: The common clay mineral of kaolin was selected as an additive into Zhundong coal during combustion. Sodium retention rates and coal ash fusion temperatures were investigated at different blending ratios and temperatures. XRD and ternary phase diagram were used to identify mineral transformations at high temperatures. The results show that the sodium retention rates increase rapidly with blending ratio from 0~2%, slowly from 2%~5% and decrease slightly with increasing temperature. The ash fusion temperatures of coal blended with additive initially decrease slowly, then decrease rapidly and finally increase with increasing blending ratio, reaching about 1 200 ℃ at 3%. The results of XRD and ternary phase diagram analysis show that the change of ash fusion temperature is due to the mineral content changes of rankinite, gehlenite and anorthite. The lowest ash fusion temperatures at the blending ratios of 3%and 4% are mainly caused by the low temperature eutectic phenomenon. The sodium retention rate reaches more than 60% and ash fusion temperature reaches about 1 300 ℃ at blending ratio of 2%, which is conductive to solid-state slag-tap boiler. The ash fusion temperature is about 1 200 ℃ at blending ratio of 3.0~4.0%, which is suitable for liquid-state slag-tap boiler.
- Zhundong coal /
- kaolin /
- sodium retention rate /
- ash fusion temperature /
- eutectic phenomenon

HTML全文

参考文献(30)

杨忠灿, 刘家利, 何红光. 新疆准东煤特性研究及其锅炉选型[J]. 热力发电, 2010, 39(8): 38-40. (YANG Zhong-can, LIU Jia-li, HE Hong-guang. Study on properties of Zhundong coal in xinjiang region and type-selection for boilers burning this coal sort[J]. Therm Pow Gen, 2010, 39(8): 38-40.)

张守玉, 陈川, 施大钟, 吕俊复, 王健, 郭熙, 董爱霞, 熊绍武. 高钠煤燃烧利用现状[J]. 中国电机工程学报, 2013, 33(5): 1-12. (ZHANG Shou-yu, CHEN Chuan, SHI Da-zhong, LV Jun-fu, WANG Jian, GUO Xi, DONG Ai-xia, XIONG Shao-wu. Situation of combustion utilization of high sodium coal[J]. Proc CSEE, 2013, 33(5): 1-12.)

王伯春, 郑楚光, 曾羽健. 煤燃烧过程中矿物质蒸发与煤灰的沉积特性[J]. 燃烧科学与技术, 1995, 1(4): 305-311. (WANG Bo-chun, ZHEN Chu-guang, ZENG Yu-jian. The relation between evaporation of minerals and coal ashes deposition during coal combustion[J]. J Combust Sci Technol, 1995, 1(4): 305-311.)

张军, 汉春利. 煤中碱金属及其在燃烧中的行为[J]. 热能动力工程, 1999, 14(2): 83-85. (ZHANG Jun, HAN Chun-li. Various forms of alkali metal in coal and its behavior during coal combustion(J). J Eng Therm Energy Pow, 1999, 14(2): 83-85.)

汉春利, 张军, 刘坤磊, 徐益谦. 煤中钠存在形式的研究[J]. 燃料化学学报, 1999, 27(6):19-23. (HAN Chun-li, ZHANG Jun, LIU Kun-lei, XU Yi-qian. Modesofoccurrence of sodium in coals[J]. J Fuel Chem Technol, 1999, 27(6): 19-23.)

SPIRO C L, WONG J, LYTLE F W, GREEGOR R B, MAYLOTTE D H, LAMSON S H. Forms of potassium in coal and its combustion products[J]. Fuel, 1986, 65(3): 327-336.

OLESCHKO H, MVLLER M. Influence of coal composition and operating conditions on the release of alkali species during combustion of hard coal[J]. Energy Fuels, 2007, 21(6): 3240-3248.

韩克鑫, 黄镇宇, 王智化, 周俊虎. 准东煤灰渣烧结熔融过程中钠基化合物作用机理研究[J]. 燃料化学学报, 2015, 43(1): 22-26. (HAN Ke-xin, HUANG Zhen-yu, WANG Zhi-hua, ZHOU Jun-hu. Action mechanism of sodium compounds inZhundong coal ash on the process of sintering and fusion[J]. J Fuel Chem Technol, 2015, 43(1): 22-26.)

刘敬, 王智化, 项飞鹏, 黄镇宇, 刘建忠, 周俊虎, 岑可法. 准东煤中碱金属的赋存形式及其在燃烧过程中的迁移规律实验研究[J]. 燃料化学学报, 2014, 42(3): 316-322. (LIU Jing, WANG Zhi-hua, XIANG Fei-peng, HUANG Zhen-yu, LIU Jian-zhong, ZHOU Jun-hu, CEN Ke-fa. Modes of occurrence andtransformation ofalkali metals in Zhundong coal during combustion[J]. J Fuel Chem Technol, 2014, 42(3): 316-322.)

RAASK E. Mineral impurities in coal combustion: behavior, problems, and remedial measures[M].Hem Publ Corp Wash D.C., 1985.

GLAZER M P, KHAN N A, JONG W D, SPLIETHOFF H, SCHVRMANN H, MONKHOUSE P. Alkali metals in circulating fluidized bed combustion of biomass and coal: Measurements and chemical equilibrium analysis[J]. Energy Fuels, 2005, 19(5):1889-1897.

卫小芳, 刘铁峰, 黄戒介, 房倚天, 王洋. 澳大利亚高盐煤中钠在热解过程中的形态变迁[J]. 燃料化学学报, 2010, 38(2): 144-148. (WEI Xiao-fang, LIU Tie-feng, HUANG Jie-jie, FANG Yi-tian, WANG Yang. Transformation of Na in an australian high-sodium coal during pyrolysis[J]. J Fuel Chem Technol, 2010, 38(2): 144-148.)

STEFFIN C, WANZL W, HEEK W. Study on the evaporation of alkali in coal ashes(R). Proc ICCS97, 1997.

村上高広, 李文. 煤燃烧场中碱金属化合物的基础排放特性[J]. 煤质技术, 2000, (3): 37-42. (SHUSHANG Gao-guang, LI Wen. The basic emission characteristic ofalkali metal compounds in the coal combustionfield[J]. Co Qual Technol, 2000, (3): 37-42.)

SHADMAN F, PUNJAK W A. Thermochemistry of alkali interactions with refractory adsorbents[J]. Thermochim. Acta, 1988, 131(88):141-152.

刘敬. 准东煤燃烧过程及粘污积灰机理研究[D]. 浙江大学, 2014. (LIU Jing. Mechanism research on combustion process and fouling of Zhundongcoal[D]. Zhejiang University. 2014.)

李依丽, 高晋生, 吴幼青. 高温气体中碱蒸气吸附剂的研究[J]. 煤炭学报, 2003, 28(2): 178-182. (LI Yi-li, GAO Jin-sheng, WU You-qing. Study on alkali vapor removing sorbent in high temperature gas[J]. J China Coal Soc, 2003, 28(2): 178-182.)

李依丽, 吴幼青, 高晋生. 几种天然矿物脱除高温气体中碱蒸气研究[J]. 燃料化学学报, 2003, 31(1): 44-48. (LI Yi-li, WU You-qing, GAO Jin-sheng. Removing alkali vapor at high temperature by natural minerals[J]. J Fuel Chem Technol, 2003, 31(1): 44-48.)

KYI S, CHADWICK B L. Screening of potential mineral additives for use as fouling preventatives in Victorian brown coal combustion[J]. Fuel, 1999, 78(7): 845-855.

张杰. 神木煤一维炉热态结渣过程和添加剂防结渣的试验研究[D]. 杭州: 浙江大学, 2011. (ZHANG Jie. Experimental study on slagging process and anti-slagging with additives of shenmu coal on one-dimensional furnace[D]. Hangzhou: Zhejiang University, 2011.)

HUANG Z, LI Y, LU D, ZHOU Z, WANG Z, ZHOU J, CEN K. Improvement of the coal ash slagging tendency by coal washing and additive blending with mullitegeneration[J]. Energy Fuels, 2013, 27(4): 2049-2056.

王泉清, 曾蒲君. 高岭石对神木煤灰熔融性的影响[J]. 煤化工, 1997, (3): 40-45. (WANG Qing-quan, ZENG Pu-jun. Influence of kaolinites on the fusibility of Shenmu coal ash[J]. Coal Chem Ind, 1997, (3): 40-45.)

马岩, 黄镇宇, 唐慧儒, 王智化, 周俊虎, 岑可法. 准东煤灰化过程中的矿物演变及矿物添加剂对其灰熔融特性的影响[J]. 燃料化学学报, 2014, 42(1): 20-25. (MA Yan, HUANG Zhen-yu, TANG Hui-ru, WANG Zhi-hua, ZHOU Jun-hu, CEN Ke-fa. Mineral conversion of Zhundong coal during ashing process and the effect of mineral additives on its ash fusion characteristics[J]. J Fuel Chem Technol, 2014, 42(1): 20-25.)

邱忠, 梁进林. 循环流化床锅炉燃烧新疆准东五彩湾煤的对策探讨[J]. 应用能源技术, 2012, (12): 16-19. (QIU Zhong, LIANG Jin-lin. Circulating fluidized bed boiler burning Xinjiang Wucaiwan area in Zhundong coal measures[J]. Appl Energy Technol, 2012, (12): 16-19.)

刘璀巍, 胡龙. 苇湖梁电厂锅炉燃用新疆准东煤特性研究[J]. 发电与空调, 2012, 33(6): 45-47. (LIU Cui-wei, HU Long. Study on propertites of zhundong coal in Xinjiang region[J]. Ref Air Cond Elec Pow Mach, 2012, 33(6): 45-47.)

史永胜, 卢红玲. 锅炉掺烧高碱金属煤的试验研究[J]. 华北电力技术, 2013, (1): 39-42. (SHI Yong-sheng, LU Hong-ling. Research of blending combustion of boiler fueled with high alkali metal coal[J]. North Chin Elec Pow, 2013, (1): 39-42.

李建欣. XRD全谱拟合精修对贵州煤中矿物质的定量研究[D]. 河南理工大学, 2009. (LI Jian-xin. X-ray diffractionrietveld refinement method quantitative phase analysis minerals in coals Guizhouprovince[D]. Henan Polytechnic University, 2009.)

李勇, 肖军. 燃煤过程中碱金属赋存迁移规律及相关研究进展[J]. 洁净煤技术, 2005, 11(1): 39-44. (LI Yong, XIAO Jun. The occurrence and migration mechanism of alkali metal during coal-fired process and research progress[J]. Clean Coal Technol, 2005, 11(1): 39-44.)

WANG L, SKREIBERG, BECIDAN M. Investigation of additives for preventing ash fouling and sintering during barley straw combustion[J]. Appl Therm Eng, 2014, 11(2): 1262-1269.

李文, 白进. 煤的灰化学(M). 北京: 科学出版社, 2013. (LI Wen, BAI jin. Chemistry of ash from coal(M). Beijing: Science Press, 2013.)

施引文献

资源附件(0)

访问统计