Effect of humic acid on equilibrium adsorption of water of Shengli lignite
-
摘要: 研究了褐煤中重要的成分腐殖酸对褐煤水分的影响。测定了内蒙胜利褐煤中腐殖酸含氧官能团的含量,并分析了褐煤、棕黑腐殖酸和残余煤的等温吸附和脱附曲线。通过Dent吸附等温模型研究了褐煤和棕黑腐殖酸第一层吸附和第二层吸附。结果表明,胜利褐煤2/5羧基和1/5羟基是由腐殖酸提供的。棕黑腐殖酸相对褐煤孔径和孔容较小,不利于水簇的形成。腐殖酸对褐煤的复吸水是不利的。Abstract: The effect of humic acid, an important component of lignite, on the water content in Shengli lignite was studied. The content of oxygen containing functional groups of humic acid in Shengli lignite was determined. The isothermal adsorption and desorption curves of the lignite, brown humic acid and the residual coal were analyzed. Further the primary and secondary site adsorption of the lignite, brown humic acid and the residual coal were studied. The results show that 2/5 carboxyl and 1/5 hydroxyl in Shengli lignite are provided by humic acid. The pore size and pore volume of brown humic acid are smaller than those of the lignite. So brown humic acid is unfavorable for the formation of water clusters. The humic acid is adverse to equilibrium adsorption of water for Shengli lignite.
-
Key words:
- lignite /
- humic acid /
- equilibrium adsorption of water /
- isothermal adsorption
-
表 1 原煤的工业分析
Table 1 Proximate analysis of the raw coal sample
Proximate analysis w/% Mad Ad Vd FCd Vdaf FCdaf 14.44 16.00 41.19 42.81 49.04 50.96 表 2 原煤的腐殖酸含量测定
Table 2 Analysis of humic acid content
Total humic acid w/% Brown humic acid w/% Fulvic acid w/% 30.22 25.64 4.58 表 3 钠元素含量的测定
Table 3 Analysis of Na
Raw coal w/% Brown humic acid w/% Residual coal w/% 1.00 0.35 17.49 表 4 含氧官能团的衡算
Table 4 Balance of oxygen containing functional groups
Sample Content w/% Total acidity /(mmol·g-1) Carboxyl /(mmol·g-1) Hydroxyl /(mmol·g-1) Brown humic acid (measure) 25.64 7.32 4.73 2.59 Fulvic acid (measure) 4.58 9.00 7.57 1.43 Residual coal (measure) 69.78 7.16 3.19 3.97 Raw coal (calculation) 100.00 7.29 3.79 3.53 Raw coal (measure) 7.38 3.85 3.50 表 5 腐殖酸含氧官能团对褐煤含氧官能团的贡献
Table 5 Contribution of oxygen functional groups of humic acid to the oxygen containing functional groups of brown coal
Sample Carboxyl /(mmol·g-1) Hydroxyl /(mmol·g-1) Brown humic acid 1.21 0.66 Fulvic acid 0.35 0.065 Raw coal 3.85 3.53 Contribution of total humic acid 40.52% 20.54% 表 6 孔容、孔径和比表面积的测定
Table 6 Determination of pore volume, pore size and specific surface area
Sample Pore volume v/(cm3·g-1) Pore size d/nm Specific surface area (BET) A/(m2·g-1) Raw coal 2.59×10-2 35.04 2.95 Brown humic acid 1.31×10-2 5.23 10.00 Residual coal 6.15×10-3 39.94 0.616 -
[1] 刘英鹏, 杨晴, 胡敏, 杨海平, 王贤华, 陈汉平.褐煤干燥后水分复吸规律及平衡含水率预测[J].煤炭学报, 2015, 40(11):2661-2667. http://www.wenkuxiazai.com/doc/2e1d959069eae009581beced.htmlLIU Ying-peng, YANG Qing, HU Min, YANG Hai-ping, WANG Xian-hua, CHEN Han-ping. Investigation on the moisture reabsorption law of lignite after drying and the prediction of equilibrium moisture content[J]. J Chin Coal Soc, 2015, 40(11):2661-2667. http://www.wenkuxiazai.com/doc/2e1d959069eae009581beced.html [2] 刘红缨, 郜翔, 张明阳, 朱彦敏, 朱书全.水热法改性褐煤及含氧官能团与水相互作用的研究[J].燃料化学学报, 2014, 42(3):284-289. http://rlhxxb.sxicc.ac.cn/CN/abstract/abstract18368.shtmlLIU Hong-ying, GAO Xiang, ZHANG Ming-yang, ZHU Yan-min, ZHU Shu-quan. Study on lignite modified by hydrothermal and the interaction between the oxygen containing functional groups and water[J]. J Fuel Chem Technol, 2014, 42(3):284-289. http://rlhxxb.sxicc.ac.cn/CN/abstract/abstract18368.shtml [3] 徐鑫, 熊志军.国内外煤炭提质技术应用现状[J].中国煤炭, 2013, 39(12):133-137. http://www.cqvip.com/QK/95382A/201312/47994908.htmlXU Xin, XIONG Zhi-jun. The current application situation of upgrading technology of domestic and international coal[J]. Chin Coal, 2013, 39(12):133-137. http://www.cqvip.com/QK/95382A/201312/47994908.html [4] 杜敬文, 殷甲楠, 樊丽华, 梁英华.褐煤利用技术现状[J].洁净煤技术, 2015, 21(1):73-76. http://www.cqvip.com/QK/98393X/201501/664233753.htmlDU Jing-wen, YIN Jia-nan, FAN Li-hua, LIANG Ying-hua. Status of lignite utilization technologies[J]. Clean Coal Technol, 2015, 21(1):73-76. http://www.cqvip.com/QK/98393X/201501/664233753.html [5] 仇欢欢, 刘生玉.含氧基团含量对褐煤水分回吸性能的影响研究[J].煤炭科学技术, 2014, 42(3):103-107. http://www.cnki.com.cn/Article/CJFDTotal-MTKJ201403029.htmCHOU Huan-huan, LIU Shen-yu. Research on oxygen-containing functional groups content affected to lignite moisture Re-adsorption performance[J]. Coal Sci Technol, 2014, 42(3):103-107. http://www.cnki.com.cn/Article/CJFDTotal-MTKJ201403029.htm [6] ALLARDICE D J, CLEMOW L M, FAVAS G, JACKSON W R, MARSHALL M, SAKUROVS R. The characterisation of different forms of water in low rank coals and some hydrothermally dried products[J]. Fuel, 2003, 82(6):661-667. doi: 10.1016/S0016-2361(02)00339-3 [7] RYUICHI K, YASUSHI M, KEIZO O. Water absorption by coals:Effects of pore structure and surface oxygen[J]. Fuel, 1986, 65(2):288-291. doi: 10.1016/0016-2361(86)90023-2 [8] CHARRIERE D, BEHRA P. Water sorption on coals[J]. J Colloid Inter Sci, 2010, 34(4):460-467. [9] 岳廷盛, 程家安, 马沛岚.褐煤腐植酸基本性能研究[J].兰州大学学报, 1995, 31(2):82-85. http://www.cqvip.com/qk/95222X/199502/1637457.htmlYUE Ting-sheng, CHEN Jia-an, MA Pei-Lan. Study on the properties of humic acid extracted from brown coal[J]. J Lanzhou Univ, 1995, 31(2):82-85. http://www.cqvip.com/qk/95222X/199502/1637457.html [10] 王高伟, 胡光洲, 孔倩, 董洁.煤炭腐植酸的基本性能及其工农业应用[J].煤炭技术, 2007, 26(11):111-114. http://www.cnki.com.cn/Article/CJFDTOTAL-MTJS200711057.htmWANG Gao-wei, HU Guang-zhou, KONG Qian, DONG Jie. Properties of humic acid in coal and its applications in industry and agriculture[J]. Coal Technol, 2007, 26(11):111-114. http://www.cnki.com.cn/Article/CJFDTOTAL-MTJS200711057.htm [11] 周霞平.腐植酸应用中的化学基础[M].北京:化学工业出版社, 2007.ZHOU Xia-ping. Basic Chemistry of Application of Humic Acid[M]. Beijing:Chemical Industry Press, 2007. [12] 郭晓峰.腐植酸的胶体性质[J].腐植酸, 1996, (1):1-2. http://www.cnki.com.cn/Article/CJFDTOTAL-FZSA199601000.htmGUO Xiao-feng. The colloidal properties of humic acid[J]. Humic Acid, 1996, (1):1-2. http://www.cnki.com.cn/Article/CJFDTOTAL-FZSA199601000.htm [13] MARTINA Š, ZUZANA W, OLDRICH P. Water vapour adsorption on coal[J]. Fuel, 2011, 90(5):1892-1899. doi: 10.1016/j.fuel.2011.01.005 [14] 成绍鑫.腐植酸类物质概论[M].北京:化学工业出版社, 2007.CHEN Shao-xin. The Introduction of Humic Substances[M]. Beijing:Chemical Industry Press, 2007. [15] NUGROHO Y S, MCINTOSH A C, GIBBS B M. Low-temperature oxidation of single and blended coals[J]. Fuel, 2000, 79(15):1951-1961. doi: 10.1016/S0016-2361(00)00053-3 [16] 李艳红, 庄锐, 张政, 赵文波, 王平艳, 夏举佩, 李国斌.褐煤腐殖酸的结构、组成和性质的研究进展[J].化工进展, 2015, 34(8):3147-3157. http://www.cnki.com.cn/Article/CJFDTOTAL-HGJZ201508043.htmLI Yan-hong, ZHANG Rui, ZHANG Zhen, ZHAO Wen-bo, WANG Ping-yan, XIA Ju-pei, LI Guo-bin. Research on the structure, chemical composition and characterization of humic acid from liginite[J]. Chem Ind Eng Prog, 2015, 34(8):3147-3157. http://www.cnki.com.cn/Article/CJFDTOTAL-HGJZ201508043.htm [17] YU J L, TAHMASEBI A, HAN Y N, YIN F K, LI X C. A review on water in low rank coals:The existence, interaction with coal structure and effects on coal utilization[J]. Fuel Process Technol, 2013, 106:9-20. doi: 10.1016/j.fuproc.2012.09.051 [18] CEGLARSKA-STEFANSKA G, CZAPLINSKI A. Correlation between sorption and dilatometric processes in hard coals[J]. Fuel, 1993, 72(3):413-417. doi: 10.1016/0016-2361(93)90064-9 [19] ALAN L M, WESLEY A B, MICHAEL A W. Characterization of water adsorbed on bituminous coals[J]. Energy Fuels, 2003, 17(1):107-112. doi: 10.1021/ef020101d [20] 刘祥春, 冯莉, 王新华, 张曼, 史啸峰. K+、Na+、Ca2+、Mg2+对胜利褐煤平衡复吸水的影响[J].燃料化学学报, 2014, 42(4):385-391. http://rlhxxb.sxicc.ac.cn/CN/abstract/abstract18383.shtmlLIU Xiang-chun, FEN Li, WANG Xin-hua, ZHANG Man, SHI Xiao-feng. Effect of K+、Na+、Ca2+、Mg2+ on equilibrium adsorption of water content of Shengli lignite[J]. J Fuel Chem Technol, 2014, 42(4):385-391. http://rlhxxb.sxicc.ac.cn/CN/abstract/abstract18383.shtml