Effect of Fe2O3 on the pyrolysis of two demineralized coal using in-situ pyrolysis photoionization time-of-flight mass spectrometry

ZHANG Xue-hui; ZHU Jia-long; BAN Yan-peng; LIU Fang-gang; JIN Li-jun; HU Hao-quan

doi:10.1016/S1872-5813(21)60065-8

Volume 49 Issue 5

May 2021

Turn off MathJax

Article Contents

Article Navigation > Journal of Fuel Chemistry and Technology > 2021 > 49(5): 589-597

ZHANG Xue-hui, ZHU Jia-long, BAN Yan-peng, LIU Fang-gang, JIN Li-jun, HU Hao-quan. Effect of Fe2O3 on the pyrolysis of two demineralized coal using in-situ pyrolysis photoionization time-of-flight mass spectrometry[J]. Journal of Fuel Chemistry and Technology, 2021, 49(5): 589-597. doi: 10.1016/S1872-5813(21)60065-8

Citation:

ZHANG Xue-hui, ZHU Jia-long, BAN Yan-peng, LIU Fang-gang, JIN Li-jun, HU Hao-quan. Effect of Fe₂O₃ on the pyrolysis of two demineralized coal using in-situ pyrolysis photoionization time-of-flight mass spectrometry[J]. Journal of Fuel Chemistry and Technology, 2021, 49(5): 589-597. doi: 10.1016/S1872-5813(21)60065-8

Citation:

PDF( 3110 KB)

Effect of Fe₂O₃ on the pyrolysis of two demineralized coal using in-situ pyrolysis photoionization time-of-flight mass spectrometry

doi: 10.1016/S1872-5813(21)60065-8

State Key Laboratory of Fine Chemicals, Institute of Coal Chemical Engineering, School of Chemical Engineering, Dalian University of Technology, Dalian 116024, China

Funds: The project was supported by National Key R & D Program of China (2016YFB0600301) and The Fundamental Research Funds for the Central Universities (DUT2018TB02)

Received Date: 2020-12-30
Rev Recd Date: 2021-02-13

Available Online: 2021-03-16

Publish Date: 2021-05-28

Abstract

Abstract

Influence of Fe₂O₃ on the pyrolysis products distribution of demineralized Hongshaquan (HSQ) and Daliuta (DLT) coal was investigated by a novel in-situ pyrolysis vacuum ultraviolet single photon ionization time-of-flight mass spectrometry. The experiment samples were obtained by mechanical mixing of Fe₂O₃ and demineralized coal from acid elution with the mass ratio of 10∶1, 5∶1 and 2∶1. Due to the characteristics of in-situ sampling, soft ionization and high vacuum environment, the initial pyrolysis volatiles including alkenes, aromatic hydrocarbons, phenols, bi-phenols and a small amount of sulfur and nitrogen-containing substances can be detected. The results show that Fe₂O₃ has similar influence on the products distribution of two demineralized coal, and it is relatively stronger on DLT coal than that on HSQ. With the increase of Fe₂O₃ content, the light fraction content is promoted such as alkenes and aromatic hydrocarbons, but bi-phenols are obviously inhibited. Correspondingly, the heavy products are also decreased, and the evolution peak temperatures of the product increase. Fe₂O₃ is successively reduced to FeO and Fe while transforming heavy components into light components. The increase of aliphatic carbon (or aromatic hydrocarbon substituted carbon) during coal pyrolysis process is mainly responsible for the decrease pyrolysis peak temperature.
- coal pyrolysis,
- photoionization,
- primary volatiles,
- PI-TOF MS,
- Fe₂O₃

FullText(HTML)

References(25)

References

[1]	2020中国统计年鉴[M]. 北京: 中华人民共和国国家统计局, 2020. 2020 China Statistical Yearbook[M]. Beijing: National Bureau of Statistics of People's Republic of China, 2020.
[2]	郭富强, 丁建伟, 刘昆仑, 俞乔. 煤炭清洁高效利用发展现状及趋势展望[J]. 煤炭加工与综合利用,2019,12:55−60. GUO Fu-qiang, DING Jian-wei, LIU Kun-lun, YU Qiao. Current development situation and tendency prospect for coal clean and efficient utilization[J]. Coal Process Compr Util,2019,12:55−60.
[3]	WANG P, JIN L, LIU J, ZHU S, HU H. Isotope analysis for understanding the tar formation in the integrated process of coal pyrolysis with CO₂ reforming of methane[J]. Energy Fuels,2010,24(8):4402−4407. doi: 10.1021/ef100637k
[4]	刘振宇. 煤化学的前沿与挑战: 结构与反应[J]. 中国科学: 化学,2014,44(9):1431−1438. LIU Zhen-yu. Advancement in coal chemistry: Structure and reactivity[J]. Sci China Ser B,2014,44(9):1431−1438.
[5]	2016中国矿产资源报告[M]. 北京: 中华人民共和国国土资源部, 2016. 2016 China Mineral Resources[M]. Beijing: Ministry of Land and Resources, P. R. C.
[6]	KATALAMBULA H, GUPTA R. Low-grade coals: A review of some prospective upgrading technologies[J]. Energy Fuels,2009,23(7):3392−3405. doi: 10.1021/ef801140t
[7]	汪亚斌, 胡金余, 李增勃, 李文选. 煤热解技术研究进展[J]. 炼油与化工,2020,4:8−11. WANG Ya-bin, HU Jin-yu, LI Zeng-bo, LI Wen-xuan. Research progress of coal pyrolysis technology[J]. Ref Chem Ind,2020,4:8−11.
[8]	朱廷钰, 王洋. 氧化铁与碳酸钾对煤温和气化的影响[J]. 化学反应工程与工艺,2000,16(2):203−207. ZHU Ting-yu, WANG Yang. Effect of Fe₂O₃-K₂CO₃ on coal mild gasification[J]. Chem React Eng Technol,2000,16(2):203−207.
[9]	CHO W, KIM S, CHO H K. Characterization of made of solvent extracted coals[J]. Korean J Chem Eng,2012,29(2):190−195. doi: 10.1007/s11814-011-0160-z
[10]	贺璐. 煤热解与铁矿石还原耦合工艺的基础研究[D]. 北京: 中国科学院过程工程研究所, 2018. HE Lu. Fundamentals on integration of coal pyrolysis with iron ore reduction process[D]. Beijing: Institute of Process Engineering, Chinese Academy of Sciences, 2018.
[11]	梁虎珍, 王传格, 曾凡桂, 李美芬, 相建华. 应用红外光谱研究脱灰对伊敏褐煤结构的影响[J]. 燃料化学学报,2014,42(2):129−137. LIANG Hu-zhen, WANG Chuan-ge, ZENG Fan-gui, LI Mei-fen, XIANG Jian-hua. Effect of demineralization on lignite structure from Yinmin coalfield by FT-IR investigation[J]. J Fuel Chem Technol,2014,42(2):129−137.
[12]	ZHOU Y, LI G, JIN L J, ZHOU J, WANG J F, LI Y, HU H Q. In situ analysis of catalytic effect of calcium nitrate on shenmu coal pyrolysis with pyrolysis vacuum ultraviolet photoionization mass spectrometry[J]. Energy Fuels,2018,32:1061−1069. doi: 10.1021/acs.energyfuels.7b02385
[13]	YANG Z, ZHANG T, PAN Y, HONG X, TANG Z, QI F. Electrospray/VUV single-photonioniza tion mass spectrometry for the analysis of organic compounds[J]. J Am Soc Mass Spectr,2009,20(3):430−434. doi: 10.1016/j.jasms.2008.10.026
[14]	ZHOU L, ENAKONDA R L, HARB M, SARH Y, AGUILAR-TAPIA A, OULD-CHIKH S, HAZEMANN J-L, LI J, WEI N N, GARY D, DEL-GALLO P, BASSET J-M. Fe catalysts for methane decomposition to produce hydrogen and carbon nano materials[J]. Appl Catal B: Environ,2017,208:44−59. doi: 10.1016/j.apcatb.2017.02.052
[15]	LINSTROM P J. NIST Chemistry Webbook[M]. https://webbook.nist.gov/chemistry/. 2018.
[16]	NORDGREEN T, LILIEDAHL T, SJOSTROM K. Metallic iron as a tar breakdown catalyst related to atmospheric, fluidised bed gasification of biomass[J]. Fuel,2006,85:689−694. doi: 10.1016/j.fuel.2005.08.026
[17]	HE L, LI S, LIN W. Catalytic cracking of pyrolytic vapors of low-rank coal over limonite ore[J]. Energy Fuels,2016,30:6984−6990. doi: 10.1021/acs.energyfuels.6b01182
[18]	LI X, HUI H L, LI S G, HE L, CUI L J. Integration of coal pyrolysis process with iron ore reduction: Reduction behaviors of iron ore with benzene-containing coal pyrolysis gas as a reducing agent[J]. Chin J Chem Eng,2016,24(6):811−817. doi: 10.1016/j.cjche.2015.12.020
[19]	王美君, 杨会民, 何秀风, 常丽萍. 铁基矿物质对西部煤热解特性的影响[J]. 中国矿业大学学报,2010,39(3):426−430. WANG Mei-jun, YANG Hui-min, HE Xiu-feng, CHANG Li-ping. Effect of Fe-based minerals on pyrolysis characteristics of coal from western China[J]. J China Univ Min Technol,2010,39(3):426−430.
[20]	王德超. 铁基氧化物催化重油部分氧化提质及过程耦合研究[D]. 大连: 大连理工大学, 2020. WANG De-chao. Upgrading of heavy oil with partial oxidation and process coupling over iron-based oxides[D]. Dalian: Dalian University of Technology, 2020.
[21]	HE L, HUI H L, LI S G, LIN W G. Production of light aromatic hydrocarbons by catalytic cracking of coal pyrolysis vapors over natural iron ores[J]. Fuel,2018,216:227−232. doi: 10.1016/j.fuel.2017.12.005
[22]	宋强, 赵洪宇, 王雪强, 顾秋香, 梁新星, 舒新前. 赤铁矿对2种低阶煤热解特性影响[J]. 西安科技大学学报,2017,37(2):260−266. SONG Qiang, ZHAO Hong-yu, WANG Xue-qiang, GU Qiu-xiang, LIANG Xin-xing, SHU Xin-qian. Effect of hematite on pyrolysis characteristics of two low-rank coal[J]. J Xi'an Univ Sci Technol,2017,37(2):260−266.
[23]	WANG D C, JIN L J, LI Y, WEI B Y, YAO D M, WANG T T, HU H Q. Integrated process of coal tar upgrading and in-situ reduction of Fe₂O₃[J]. Fuel Process Technol,2019,191:20−28. doi: 10.1016/j.fuproc.2019.03.024
[24]	QIU S X, ZHANG S F, SUO G S, QIU Z B, YIN C, LI Y, HU M L, XIAO X, WEN L Y. Effects of Fe₂O₃ addition on the thermoplasticity and structure of coking coal matrix during thermoplastic stage of pyrolysis[J]. Fuel,2020,260:116305. doi: 10.1016/j.fuel.2019.116305
[25]	许莹, 孙小星, 胡宾生. 催化剂对混合煤在快速热解过程中的影响[J]. 化学工程,2007,35(4):65−67,71. XU Ying, SUN Xiao-xing, HU Bin-sheng. Effect of combustion catalysts on mixed-coal rapid pyrolysis[J]. Chem Eng (China),2007,35(4):65−67,71.