Promotion effect of tungsten addition on N2 selectivity of MnOx-Fe2O3 for NH3-SCR

WANG Ji-feng; WANG Hui-min; ZHANG Ya-qing; ZHANG Qiu-lin; NING Ping

Volume 47 Issue 7

Jul. 2019

Turn off MathJax

Article Contents

Article Navigation > Journal of Fuel Chemistry and Technology > 2019 > 47(7): 814-822

WANG Ji-feng, WANG Hui-min, ZHANG Ya-qing, ZHANG Qiu-lin, NING Ping. Promotion effect of tungsten addition on N2 selectivity of MnOx-Fe2O3 for NH3-SCR[J]. Journal of Fuel Chemistry and Technology, 2019, 47(7): 814-822.

Citation:

WANG Ji-feng, WANG Hui-min, ZHANG Ya-qing, ZHANG Qiu-lin, NING Ping. Promotion effect of tungsten addition on N₂ selectivity of MnO_x-Fe₂O₃ for NH₃-SCR[J]. Journal of Fuel Chemistry and Technology, 2019, 47(7): 814-822.

Citation:

PDF( 1357 KB)

Promotion effect of tungsten addition on N₂ selectivity of MnO_x-Fe₂O₃ for NH₃-SCR

Faculty of Environmental Science and Engineering, Kunming University of Science and Technology, Kunming 650500, China

Funds:

the National Natural Science Foundation of China 21307047

Analysisand Testing Foundation of Kunming University of Science and Technology 2018M20172207016

Analysisand Testing Foundation of Kunming University of Science and Technology 2018M20172107028

More Information

Corresponding author: ZHANG Qiu-li, E-mail: qiulinzhang_kmust@163.com
Received Date: 2019-01-22
Rev Recd Date: 2019-03-24

Available Online: 2021-01-23

Publish Date: 2019-07-10

Abstract

Abstract

A series of tungsten modified MnO_x-Fe₂O₃ catalysts with different tungsten contents were prepared by sol-gel method. The influence of tungsten on N₂ selectivity of NH₃-SCR reaction was investigated particularly. Physical and chemical properties of the catalysts were characterized by means of XRD, BET, XPS, H₂-TPR, Raman and in situ DRIFTS. The results showed that N₂ selectivity of NH₃-SCR at high temperature was significantly improved by introducing tungsten. NH₃-SCR possessed the best catalytic performance when the tungsten content was 15% (mass ratio), as well as N₂O concentration was less than 0.003% within the range of 50-250℃. The primary causes were the phase change from α-Fe₂O₃ to γ-Fe₂O₃ due to the introduction of appropriate amount of WO₃. Besides, the interaction between tungsten and manganese formed a new amorphous MnWO₄ and obtained a large specific surface area. In addition, the ratio of Mn⁴⁺/(Mn³⁺+Mn⁴⁺) decreased while the content of Fe²⁺ and surface chemical adsorption oxygen (O_α) increased, thus the oxidability of the catalyst was reduced. Meanwhile, tungsten doping enhanced the content and strength of Lewis acid sites on the surface of catalysts at high temperatures. Moreover, the adsorption of NH₃ was enhanced, thus, NH₃-SCR reaction was accelerated. The doping of WO₃ inhibited the deep oxidation of NO₂ to form nitrate species, reduced the content of by-product N₂O produced by nitrate species reduction, and significantly improved the NH₃-SCR activity and N₂ selectivity of WO₃-MnO_x-Fe₂O₃ catalyst at experimental temperature.
- selective catalytic reduction,
- γ-Fe₂O₃,
- high N₂ selectivity,
- acid sites

FullText(HTML)

References(53)

References

[1]	BOSCH H, JASSEN F. Catalytic reduction of nitrogen oxides. A review on the fundamentals and technology[J]. Catal Today, 1988, 4:369-532.
[2]	LIETTIA L, RAMISB G, BERTI F, TOLEDOC G, ROBBAC D, BUSCAB G, FORZATTI P. Chemical, structural and mechanistic aspects on NO_x SCR over commercial and model oxide catalysts[J]. Catal Today, 1998, 42:101-116. doi: 10.1016/S0920-5861(98)00081-9
[3]	RAMIS G, BUSCA G. On the effect of dopants and additives on the state of surface vanadyl centers of vanadia-titania catalysts[J]. Catal Lett, 1993, 18:299-303. doi: 10.1007/BF00769450
[4]	BYRNE J W, CHEN J M, SPERONELLO B K. Selective catalytic reduction of NO_x using zeolitic catalysts for high temperature applications[J]. Catal Today, 1992, 13:33-42. doi: 10.1016/0920-5861(92)80185-P
[5]	WING C W, NOBE K. Reduction of NO with NH₃ on Al₂O₃-and TiO₂-supported metal oxide[J]. Ind Eng Chem Prod Res Dev, 1986, 25:179-186. doi: 10.1021/i300022a010
[6]	ZHANG C A, CHEN T H, LIU H B, CHEN D, XU B, QING C S. Low temperature SCR reaction over nano-structured Fe-Mn oxides:Characterization, performance, and kinetic study[J]. Appl Sur Sci, 2018, 457:1116-1125. doi: 10.1016/j.apsusc.2018.07.019
[7]	CHEN X H, ZHENG Y Y, ZHANG Y B. MnO₂-Fe₂O₃ catalysts supported on polyphenylene sulfide filter felt by a redox method for the low-temperature NO reduction with NH₃[J]. Catal Commun, 2018, 105:16-19. doi: 10.1016/j.catcom.2017.09.006
[8]	WANG Z, SHEN G L, LI J Q, LIU H D, WANG Q, CHEN Y F. Catalytic removal of benzene over CeO₂-MnO_x composite oxides prepared by hydrothermal method[J]. Appl Catal B:Environ, 2013, 138-139:253-259. doi: 10.1016/j.apcatb.2013.02.030
[9]	ZHANG D S, ZHANG L, SHI L Y, FANG C. In situ supported MnO_(x)-CeO_(x) on carbon nanotubes for the low-temperature selective catalytic reduction of NO with NH₃[J]. Nanoscale, 2013, 5(3):1127-1136. doi: 10.1039/c2nr33006g
[10]	LIU F D, HE H, ZHANG C B, FENG Z C, ZHENG L R, XIE Y M, HU T D. Selective catalytic reduction of NO with NH₃ over iron titanate catalyst:Catalytic performance and characterization[J]. Appl Catal B:Environ, 2010, 96(3/4):408-420.
[11]	YAO X J, ZHANG L, LI L L, LIU L C, CAO Y, DONG X, GAO F, DENG Y, TANG C J, CHEN Z, DONG L, CHEN Y. Investigation of the structure, acidity, and catalytic performance of CuO/Ti_0.95Ce_0.05O₂ catalyst for the selective catalytic reduction of NO by NH₃ at low temperature[J]. Appl Catal B:Environ, 2014, 150/151:315-329. doi: 10.1016/j.apcatb.2013.12.007
[12]	YAO X J, KONG T T, YU S H, LI L L, YANG F M, DONG L. Influence of different supports on the physicochemical properties and denitration performance of the supported Mn-based catalysts for NH₃-SCR at low temperature[J]. Appl Sur Sci, 2017, 402:208-217. doi: 10.1016/j.apsusc.2017.01.081
[13]	SINGOREDJO L, KORVER R, KAPTEQN F, MOUHJN J. Alumina supported manganese oxides for the low temperature selective catalytic reduction of nitric oxide with ammonia[J]. Appl Catal B:Environ, 1992, 1:297-316. doi: 10.1016/0926-3373(92)80055-5
[14]	SHI Y N, CHEN S, SUN H, SHU Y, QUAN X. Low-temperature selective catalytic reduction of NO_x with NH₃ over hierarchically macro-mesoporous Mn/TiO₂[J]. Catal Commun, 2013, 42:10-13. doi: 10.1016/j.catcom.2013.07.036
[15]	LIN Q C, LI J H, MA L, HAO J M. Selective catalytic reduction of NO with NH₃ over Mn-Fe/USY under lean burn conditions[J]. Catal Today, 2010, 151(3/4):251-256. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=f10eb18f990026a3322b08e6ded5d28a
[16]	LIU F D, HE H, ZHANG C B. Novel iron titanate catalyst for the selective catalytic reduction of NO with NH₃ in the medium temperature range[J]. Chem Commun, 2008, 17:2043-2045.
[17]	XIONG Z B, LU C M, GUO D X, ZHANG X L, HAN K H. Selective catalytic reduction of NO_x with NH₃ over iron-cerium mixed oxide catalyst:Catalytic performance and characterization[J]. J Chem Technol Biot, 2013, 88(7):1258-1265. doi: 10.1002/jctb.2013.88.issue-7
[18]	ZHANG P, LI D X. Selective catalytic reduction of NO with NH₃ over iron-vanadium mixed oxide catalyst[J]. Catal Lett, 2014, 144(5):959-963. doi: 10.1007/s10562-014-1203-y
[19]	APOSTOLESCU N, GEIGERAK B, HIZBULLAH K, JANC M T, KURETI S, REICHERT D, SCHOTT F, WEISWEILER W. Selective catalytic reduction of nitrogen oxides by ammonia on iron oxide catalysts[J]. Appl Catal B:Environ, 2006, 62(1/2):104-114.
[20]	AI-ZENG M, GRVNERT W. Selective catalytic reduction of NO by ammonia over Fe-ZSM-5 catalysts[J]. Chem Commun, 1999:71-72.
[21]	SUN W B, LI X Y, ZHAO Q, MU J C, CHEN J H. Fe-Mn mixed oxide catalysts synthesized by one-step urea-precipitation method for the selective catalytic reduction of NO_x with NH₃ at low temperatures[J]. Catal Lett, 2017, 148(1):227-234.
[22]	CHEN Z H, WANG F R, LI H, YANG Q, WANG L F, LI X H. Low-temperature selective catalytic reduction of NO_x with NH₃ over Fe-Mn mixed-oxide catalysts containing Fe₃Mn₃O₈ phase[J]. Ind Eng Chem Res, 2011, 51(1):202-212.
[23]	PARK H, SHIN B, LEE H. Catalytic activity and surface characteristics of WO₃-doped MnO_x-TiO₂ catalysts for low-temperature selective catalytic reduction of NO_x with NH₃[J]. J Korean Inst Met Mater, 2016, 54(10):787-792. doi: 10.3365/KJMM.2016.
[24]	WANG X M, LI X Y, ZHAO Q D, SUN W B, TADE M, LIU S M. Improved activity of W-modified MnO_x-TiO₂ catalysts for the selective catalytic reduction of NO with NH₃[J]. Chem Eng J, 2016, 288:216-222. doi: 10.1016/j.cej.2015.12.002
[25]	SHI J, ZHANG Z H, CHEN M X, ZHANG Z X, SHANG GUAN W F. Promotion effect of tungsten and iron co-addition on the catalytic performance of MnO_x/TiO₂ for NH₃-SCR of NO_x[J]. Fuel, 2017, 210:783-789. doi: 10.1016/j.fuel.2017.09.035
[26]	SHIN B, LEE H, PARK H. Catalytic activity and surface characteristics of WO₃-doped MnO_x-TiO₂ catalysts for low-temperature selective catalytic reduction of NO_x with NH₃[J]. Korean J Met Mater, 2016, 54:787-792. doi: 10.3365/KJMM.2016.
[27]	CHOUNG J W, NAM I S, HAM S W. Effect of promoters including tungsten and barium on the thermal stability of V₂O₅/sulfated TiO₂ catalyst for NO reduction by NH₃[J]. Catal Today, 2006, 111(3/4):242-247. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=bfe6d894a0974eee82da6e2c6ee21cc4
[28]	LIU F D, SHAN W P, LIAN Z H, XIE L J, HE H. Novel MnWO_x catalyst with remarkable performance for low temperature NH₃-SCR of NO_x[J]. Catal Sci Technol, 2013, 3(10):2699-2707. doi: 10.1039/c3cy00326d
[29]	SHAN W P, LIU F D, HE H, SHI X Y, ZHANG C B. Novel cerium-tungsten mixed oxide catalyst for the selective catalytic reduction of NO_(x) with NH₃[J]. Chem Commun, 2011, 47(28):8046-8048. doi: 10.1039/c1cc12168e
[30]	SHAN W P, GENG Y, CHEN X L, HUANG N, LIU F D, YANG S J. A highly efficient CeWO_x catalyst for the selective catalytic reduction of NO_x with NH₃[J]. Catal Sci Technol, 2016, 6(4):1195-1200. doi: 10.1039/C5CY01282A
[31]	HEINZ W, ULRIKE G, PAUL R M, BRIAN B B. Immunocytochemical characterization and spatial distribution of midget bipolar cells in the macaque monkey retina[J]. Vision Res, 1994, 34:561-579. doi: 10.1016/0042-6989(94)90013-2
[32]	王琪莹, 刘自力, 邹汉波, 赵朝晖, 韦星船.表面活性剂改性对Zn/Ti-PILCs吸附剂脱硫性能的影响[J].燃料化学学报, 2011, 39(3):203-206. doi: 10.3969/j.issn.0253-2409.2011.03.008 WANG Qi-ying, LIU Zi-li, ZOU Han-bo, ZHAO Chao-hui, WEI Xing-chuan. Effect of surfactant modification on desulfurization performance of Zn/Ti-PILCs adsorbent[J]. J Fuel Chem Technol, 2011, 39(3):203-206. doi: 10.3969/j.issn.0253-2409.2011.03.008
[33]	LEE J, KWAK S Y. Mn-doped maghemite (γ-Fe₂O₃) from metal-organic framework accompanying redox reaction in a bimetallic system:The structural phase transitions and catalytic activity toward NO_x removal[J]. ACS Omega, 2018, 3:2634-2640. doi: 10.1021/acsomega.7b01865
[34]	张信莉, 王栋, 彭建升, 路春美, 徐丽婷.煅烧温度对Mn改性γ-Fe₂O₃催化剂结构及低温SCR脱硝活性的影响[J].燃料化学学报, 2015, 43(2):244-250. http://manu60.magtech.com.cn/rlhxxb/CN/abstract/abstract18581.shtml ZHANG Xin-li, WANG Dong, PENG Jian-sheng, LU Chun-mei, XU Li-ting. Effect of calcination temperature on structure of Mn Modified γ-Fe₂O₃ catalyst and denitration activity of low temperature SCR[J]. J Fuel Chem Technol, 2015, 43(2):244-250. http://manu60.magtech.com.cn/rlhxxb/CN/abstract/abstract18581.shtml
[35]	LEE J, KWAK S Y. Mn-doped maghemite (γ-Fe₂O₃) from metal-organic framework accompanying redox reaction in a bimetallic system:The structural phase transitions and catalytic activity toward NO_x removal[J]. ACS Omega, 2018, 3(3):2634-2640. doi: 10.1021/acsomega.7b01865
[36]	WANG F, GUI K T, YAO G H. The comparison about selective catalytic reduction of De-NO_x on iron-based magnetic materials[C]. Proceedings of the Chinese Society of Electrical Engineering, 2009, 29: 47-51.
[37]	王栋. Synth-maghemite(γ-Fe₂O₃)催化剂制备及其NH₃-SCR性能优化机制研究[D].济南: 山东大学, 2016. WANG Dong. Preparation of Synth-maghemite (γ-Fe₂O₃) Catalyst and Optimization of NH₃-SCR Performance[D]. Jinan: Shan Dong University, 2016.
[38]	陈嘉宁, 刘永梅. K、Mn助剂协同效应对Fe基催化剂上CO加氢制低碳烯烃反应性能的影响[J].燃料化学学报, 2013, 41(12):1488-1494. http://manu60.magtech.com.cn/rlhxxb/CN/abstract/abstract18316.shtml CHEN Jia-ning, LIU Yong-mei. Effect of synergistic effect of K and Mn additives on the performance of CO-hydrogenation of low-carbon olefins over Fe-based catalysts[J]. J Fuel Chem Technol, 2013, 41(12):1488-1494. http://manu60.magtech.com.cn/rlhxxb/CN/abstract/abstract18316.shtml
[39]	SHEBANOVA O N, LAZOR P. Raman study of magnetite (Fe₃O₄):Laser-induced thermal effects and oxidation[J]. J Raman Spectr, 2003, 34(11):845-852. doi: 10.1002/(ISSN)1097-4555
[40]	LI Y, LI Y P, WANG P F, HU W P, ZHANG S G, SHI Q, ZHAN S H. Low-temperature selective catalytic reduction of NO_x with NH₃ over MnFeO_x nanorods[J]. Chem Eng J, 2017, 330:213-222. doi: 10.1016/j.cej.2017.07.018
[41]	RAMESH K, CHEN L W, CHEN F X, LIU Y, WANG Z, HAN Y F. Re-investigating the CO oxidation mechanism over unsupported MnO, Mn₂O₃ and MnO₂ catalysts[J]. Catal Today, 2008, 131(1/4):477-482. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=24e008f52428c3c1e5eade3efffc0c7c
[42]	CASAPU M, KRÖCHER O, ELSENER M. Screening of doped MnO_xCeO₂ catalysts for low-temperature NO-SCR[J]. Appl Catal B:Environ, 2009, 88(3/4):413-419.
[43]	宋忠贤, 宁平, 李昊, 张秋林, 张金辉, 张腾飞, 黄真真.不同Ce/Mn摩尔比对CeO₂-MnO_x催化剂低温NH₃选择性催化还原NO的影响[J].分子催化, 2015, 29(5): 422-429. SONG Zhong-xian, NING Ping, LI Hao, ZHANG Qiu-lin, ZHANG Teng-fei, HUANG Zhen-zhen. Effect of different Ce/Mn molar ratios on the selective catalytic reduction of NO by CeO₂-MnO_x catalyst at low temperature NH₃[J]. J Mol Catal, 2015, 29(5): 422-429.
[44]	XU H D, LIN Q J, WANG Y, LAN L, WANG J L, CHEN Y Q. Promotional effect of niobium substitution on the low-temperature activity of a WO₃/CeZrO_x monolithic catalyst for the selective catalytic reduction of NO_x with NH₃[J]. RSC Adv, 2017, 7:47570-47582. doi: 10.1039/C7RA08429C
[45]	WANG J P, YAN Z, LIU L L, CHEN Y, ZHANG Z T, WANG X D. In situ DRIFTS investigation on the SCR of NO with NH₃ over V₂O₅ catalyst supported by activated semi-coke[J]. Appl Surf Sci, 2014, 313:660-669. doi: 10.1016/j.apsusc.2014.06.043
[46]	CHEN L, LI J H, GE M F, MA L, CHANG H Z. Mechanism of selective catalytic reduction of NO_x with NH₃ over CeO₂-WO₃ catalysts[J]. Chin J Catal, 2011, 32:836-841. doi: 10.1016/S1872-2067(10)60195-7
[47]	LIU F D, HE H, ZHANG C B, SHAN W B, SHI X Y. Mechanism of the selective catalytic reduction of NO_x with NH₃ over environmental-friendly iron titanate catalyst[J]. Catal Today, 2011, 175(1):18-25.
[48]	KANTCHEVA M. Identification stability and reactivity of NO_x species adsorbed on titania-supported manganese catalysts[J]. J Catal, 2001, 204(2):479-494. doi: 10.1006/jcat.2001.3413
[49]	LIU Z M, ZHANG S X, LI J H, MA L L. Promoting effect of MoO₃ on the NO_x reduction by NH₃ over CeO₂/TiO₂ catalyst studied with in situ DRIFTS[J]. Appl Catal B:Environ, 2014, 144:90-95. doi: 10.1016/j.apcatb.2013.06.036
[50]	MA Z R, WU X D, HANNA HARELIND, WENG D, WANG B D, SI Z C. NH₃-SCR reaction mechanisms of NbO_x/Ce_0.75Zr_0.25O₂ catalyst:DRIFTS and kinetics studies[J]. J Mol Catal A:Chem, 2016, 423:172-180. doi: 10.1016/j.molcata.2016.06.023
[51]	ZHANG R D, YANG W, LUO N, LI P X, LEI Z G, CHEN B H. Low-temperature NH₃-SCR of NO by lanthanum manganite perovskites:Effect of A-/B-site substitution and TiO₂/CeO₂ support[J]. Appl Catal B:Environ, 2014, 146:94-104. doi: 10.1016/j.apcatb.2013.04.047
[52]	TANABE K. Catalytic application of niobium compounds[J]. Catal Today, 2003, 78(1/4):65-77.
[53]	ZIOLEK M. Niobium-containing catalysts the state of the art[J]. Catal Today, 2003, 78(1/4):47-64.