Study on the influence of particle size on the ash melting behavior of Jincheng coal

ZHANG Bo; ZHANG Hong; YANG Yun-fei; HU Guang-zhou; ZHANG Peng-qi; LUN Fei

Volume 46 Issue 12

Dec. 2018

Turn off MathJax

Article Contents

Article Navigation > Journal of Fuel Chemistry and Technology > 2018 > 46(12): 1430-1436

ZHANG Bo, ZHANG Hong, YANG Yun-fei, HU Guang-zhou, ZHANG Peng-qi, LUN Fei. Study on the influence of particle size on the ash melting behavior of Jincheng coal[J]. Journal of Fuel Chemistry and Technology, 2018, 46(12): 1430-1436.

Citation:

ZHANG Bo, ZHANG Hong, YANG Yun-fei, HU Guang-zhou, ZHANG Peng-qi, LUN Fei. Study on the influence of particle size on the ash melting behavior of Jincheng coal[J]. Journal of Fuel Chemistry and Technology, 2018, 46(12): 1430-1436.

Citation:

PDF( 9226 KB)

Study on the influence of particle size on the ash melting behavior of Jincheng coal

1.
Qinhuangdao Entry-Exit Inspection and Inspection Bureau Coal Detection Technology Center, Qinhuangdao 066003, China
2.
School of Chemical Engineering and Technology, China University of Mining and Technology, Xuzhou 221116, China

Funds:

the National Natural Science Foundation of China and Shanxi Low Carbon Coal Foundation U1510106

More Information

Corresponding author: ZHANG Hong, E-mail: hzhang@cumt.edu.cn
Received Date: 2018-08-06
Rev Recd Date: 2018-09-28

Available Online: 2021-01-23

Publish Date: 2018-12-10

Abstract

Abstract

The slagging mechanism of the Jincheng coal in the ash-agglomerate fluidized bed gasification was explored. A typical Jincheng coal sampled from Shanxi, China was prepared into different particle size and the XRF, XRD, AFT, SEM and FactSage^TM were employed to study the influence of particle size on the ash content, chemical and mineral composition and ash fusibility. The results indicate that the ash chemical composition and AFTs vary little with size below 6 mm. For the pulverized samples below 0.2 mm, there are apparent differences in the chemical composition and mineral composition, especially in Fe₂O₃. Both AFT results and SEM observations show that the sample with particle size less than 45 μm has a significantly higher melting temperature than the other three samples. The slag contents calculated with FactSage^TM are consistent with the AFT results and SEM observations, which indicates that the change of ash melting behavior with particle size results from the change in chemical composition. The ternary phase diagram of SiO₂-Al₂O₃-Fe₂O₃ can be used successfully to explain the mechanism of the change of ash melting behavior with particle size for Jincheng coal.
- Jincheng coal,
- ash-agglomerate fluidized bed,
- ash fusion temperature,
- slagging

FullText(HTML)

References(17)

References

[1]	陈鹏.中国煤炭性质、分类和用[M].北京:化学工业出版社, 2007. CHEN Peng. Nature, Classification and Utilization of Coal in China[M]. Beijing:Chemical Industry Press, 2007.
[2]	房倚天, 王洋, 马小云, 黄戎介, 吴晋沪, 程中虎, 陈寒石.灰熔聚流化床粉煤气化技术加压大型化研发新进展[J].煤化工, 2007, 35(1):11-15. doi: 10.3969/j.issn.1005-9598.2007.01.003 FANG Yi-tian, WANG Yang, MA Xiao-yun, HUANG Jie-jie, WU Jin-hu, CHENG Zhong-hu, CHEN Han-shi. New progress in research and development of pressurized large-scale coal gasification technology for ash fusion fluidized bed coal gasification technology[J]. Coal Chem, 2007, 35(1):11-15. doi: 10.3969/j.issn.1005-9598.2007.01.003
[3]	李风海, 黄戒介, 房倚天, 王洋.晋城无烟煤流化床气化结渣机理的探索[J].太原理工大学学报, 2010, 41(5):666-669. http://d.old.wanfangdata.com.cn/Periodical/tylgdxxb201005048 LI Feng-hai, HUANG Jie-jie, FANG Yi-tian, WANG Yang. Exploration on slagging mechanism of Jincheng anthracite during fluidized-bed gasification[J]. J Taiyuan Univ Technol, 2010, 41(5):666-669. http://d.old.wanfangdata.com.cn/Periodical/tylgdxxb201005048
[4]	NARUSE I, KAMIHASHIRA D, KHAINIL, MIYAUCHI Y, KATO Y, YAMASHITA Y, TOMINAGA H. Fundamental ash deposition characteristics in pulverized coal reaction under high temperature conditions[J]. Fuel, 2005, 84(4):405-410. doi: 10.1016/j.fuel.2004.09.007
[5]	WU X, ZHANG Z, PIAO G, HEX, CHEN Y, KOBAYASHI N, MORI S, ITAYA Y. Behavior of mineral matters in chinese coal ash melting during char-CO₂/H₂O gasification reaction[J]. Energy Fuels, 2009, 23(5):2420-2428. doi: 10.1021/ef801002n
[6]	MATJIE RH, LI Z, WARD C R, FRENCH D. Chemical composition of glass and crystalline phases in coarse coal gasification ash[J]. Fuel, 2008, 87(6):857-869. doi: 10.1016/j.fuel.2007.05.050
[7]	WALL T F, CREELMAN R A, GUPTA R P, GUPTA S K, COIN C, LOWE A. Coal ash fusion temperatures-New characterization techniques, and implications for slagging and fouling[J]. Prog Energy Combust Sci, 1998, 24(4):345-353. doi: 10.1016/S0360-1285(98)00010-0
[8]	BARTELS M, LIN W, NIJENHUIS J. Agglomeration in fluidized beds at high temperatures:Mechanisms, detection and prevention[J]. Prog Energy Combust Sci, 2008, 34(5):633-666. doi: 10.1016/j.pecs.2008.04.002
[9]	张洪, 胡光洲, 范佳鑫, 蒲文秀, 莫言学, 哈斯, 李迎.矿物在煤粉中的分布规律研究[J].工程热物理学报, 2008, 29(7):1231-1235. doi: 10.3321/j.issn:0253-231X.2008.07.041 ZHANG Hong, HU Guang-zhou, FANG Jia-xin, PU Wen-xiu, MO Yan-xue, HA Si, LI Ying. Study on the distribution of minerals in pulverized coals[J]. J Eng Therm, 2008, 29(7):1231-1235. doi: 10.3321/j.issn:0253-231X.2008.07.041
[10]	ZHANG, H, MO Y, SUN M. Determination of the mineral distribution in pulverized coal using densitometry and laser particle sizing[J]. Energy Fuels, 2005, 19(6):2261-2267. doi: 10.1021/ef050201u
[11]	张鹏启, 杨琪琪, 屠卡滨, 王月伦, 王祖威, 刘林林.晋城粉煤煤灰不均匀熔融规律研究[J].燃料化学学报, 2018, 46(1):8-14. doi: 10.3969/j.issn.0253-2409.2018.01.002 ZHANG Peng-qi, YANG Qi-qi, TU Ka-bin, WANG Yue-lun, WANG Zu-wei, LIU Lin-lin. Study on the uneven melting law of coal ash in Jincheng[J]. J Fuel Chem T echnol, 2018, 46(1):8-14. doi: 10.3969/j.issn.0253-2409.2018.01.002
[12]	毕可军.灰融聚流化床粉煤气化装置煤气洗涤水处理改进方案探讨[J].化肥设计, 2011, 49(2):26-28. doi: 10.3969/j.issn.1004-8901.2011.02.005 BI Ke-jun. Discussion on improvement scheme of gas washing water treatment in ash fusion fluidized bed coal gasification unit[J]. Chem Fert Des, 2011, 49(2):26-28. doi: 10.3969/j.issn.1004-8901.2011.02.005
[13]	REINMÖLLER M, SCHREINER M, GUHL S, NEUROTH M, MEYER B. Formation and transformation of mineral phases in various fuels studied by different ashing methods[J]. Fuel, 2017, 202:641-649. doi: 10.1016/j.fuel.2017.04.115
[14]	CHAKRAVARTY S, MOHANTY A, BANERJEE A, TRIPATHY R, MANDAL G K, BASARIYA M R, SHARMA M. Composition, mineral matter characteristics and ash fusion behavior of some Indian coals[J]. Fuel, 2015, 150:96-101. doi: 10.1016/j.fuel.2015.02.015
[15]	REINMÖLLER M, KLINGER M, SCHREINER M. Relationship between ash fusion temperatures of ashes from hard coal, brown coal, and biomass and mineral phases under different atmospheres:A combined FactSage^TM computational and network theoretical approach[J]. Fuel, 2015, 151:118-123. doi: 10.1016/j.fuel.2015.01.036
[16]	LI F, LI Z, HUANG J, FANG Y. Understanding mineral behaviors during anthracite fluidized-bed gasification based on slag characteristics[J]. Appl Energy, 2014, 131:279-287. doi: 10.1016/j.apenergy.2014.06.051
[17]	赵斌, 王庆功, 么强, 屈婷婷, 吕俊复, 岳光溪.流化床煤颗粒分级试验研究[J].中国矿业大学学报, 2014, 43(4):678-683. http://d.old.wanfangdata.com.cn/Periodical/zgkydxxb201404017 ZHAO Bin, WANG Qing-gong, MO Qiang, QU Ting-ting, LU Jun-fu, YUE Guang-xi. Study on classification of coal particles in fluidized bed[J]. J China Univ Min Technol, 2014, 43(4):678-683. http://d.old.wanfangdata.com.cn/Periodical/zgkydxxb201404017